Section 03
TROUBLESHOOTING
Subsection 01
(TROUBLESHOOTING CHART)
03-01-6
SMR2002-020_03_01A.FM
ENGINE CONTINUALLY BACKFIRES
ENGINE DETONATION OR PINGING
OTHER OBSERVATION
POSSIBLE CAUSE
REMEDY
Weak spark
• Fouled, defective spark plugs
• Clean/replace
Spark plugs
• Ignition coil leads or wiring reversed
• Check with wiring diagram
Ignition timing/TDC setting
• Incorrect setting
• Check/reset, refer to section
ELECTRICAL SYSTEM
• Defective encoder wheel
• Check/replace, refer to section
ENGINE MANAGEMENT
Rotary valve
(
if so equipped
)
• Incorrect timing
• Check/reset, refer to ENGINE
Carburetor
(
if so equipped
)
• Carburetion too lean
• Check/adjust, refer to section FUEL
SYSTEM
Engine
• Intake leak/crankshaft seal failure
(
carburetor models
)
• Pressure check engine, refer to section
ENGINE
OTHER OBSERVATION
POSSIBLE CAUSE
REMEDY
Ignition
• Timing too far advanced
• Check/reset
• Spark plug heat range too high
• Check/change to correct range
Engine/exhaust high
temperature
• Engine overheats and exhaust
overheats
• Check, see engine overheats
• Fuel octane too low of poor quality
• Use good quality fuel
• KS disconnected or faulty
• Check, refer to ENGINE
MANAGEMENT
• Bad KS connection
• Check, refer to ENGINE
MANAGEMENT
• Bad Kostal connection (on engine)
• Check, refer to ENGINE
MANAGEMENT
www.SeaDooManuals.net
Summary of Contents for GTI 5558
