Section 11
PROPULSION SYSTEM
Subsection 02
(JET PUMP)
SMR2002-043_11_02A.FM
11-02-11
CLEANING
All Models
Thoroughly clean jet pump housing by applying Loc-
tite Stripper (P/N 293 110 004). Allow it some time
to dissolve the old dried Loctite (10 to 15 minutes).
CAUTION:
DO NOT use Loctite Stripper on wear
ring since it will cause irreparable damage to it.
Wipe Loctite Stripper with a clean cloth.
Make sure surface is cleaned and dried of Loctite
Stripper.
Sealant on the jet pump housing can be removed
with a wire brush (disc) mounted on a drill or a
scraper.
Properly clean all threads.
Remove all O-rings and clean parts in a solvent.
Carefully check water passages and oil passages.
Blow low pressure compressed air through them
and make sure they are clear.
TYPICAL
1. Water passages
2. Oil passages
Brush and clean impeller shaft threads, impeller
and drive shaft splines with Loctite Parts Cleaner
(P/N 413 711 809) or equivalent. Free threads and
splines from any residue.
CAUTION:
Be careful not to damage impeller
shaft diameter.
PARTS INSPECTION
Impeller
Visually inspect impeller splines. Check for wear or
deformation. Renew parts if damaged.
NOTE:
Check also PTO flywheel and drive shaft
condition. Refer to BOTTOM END and DRIVE SYS-
TEM.
Examine impeller in wear ring for distortion.
Check if blade tips are blunted round, chipped or
broken. Such impeller is unbalanced and will vi-
brate and damage wear ring, impeller shaft, shaft
seal or bearings. Renew if damaged.
1. Replaced if blunted round or damaged
Check impeller for cavitation damage, deep scratch-
es or any other damage.
1. Check for cavitation, deep scratches or other damage
WARNING
Technician should wear gloves when using
this cleaning product.
F01J13A
1
2
F02J0VB
1
F02J0UA
1
www.SeaDooManuals.net
Summary of Contents for GTI 5558
