Page 4
HYDR
IM
C51wd Service Guide
Safe servicing
•
The Hydrim C51wd Instrument Washer-Disinfector should only be installed
and serviced by a qualified contractor as it is an Installation Category 2 device.
SciCan shall not be liable for incidental, special or consequential damages
caused by any maintenance or services performed on the Hydrim C51wd by a
third party or for the use of equipment or parts manufactured by a third party,
including lost profits, any commercial loss, economic loss, or loss arising from
personal injury.
•
All local, regional, state, and national regulations regarding the servicing of this
class of device and safety requirements must be observed.
When the cover is removed:
•
Hazardous voltages are accessible. Disconnect the power cord before
removing the cover.
•
Sharp metal edges are exposed. Be careful, and wear long sleeves and gloves.
Power main
•
A dielectric strength test (hi-pot) must be performed on the unit if parts
associated with the power main are serviced or replaced.
Ground
•
A protective bonding impedance test (ground continuity) must be performed on the
unit if components of the protective earthing system are changed or if connections
are broken and remade.
1. Introduction
1.3 Safety Information
Safe operation
The following apply to both operators and service technicians:
•
Exercise caution and seek assistance when lifting or carrying the unit.
•
Cleaning solutions may irritate. Avoid contact with eyes, skin, and mouth.
•
Never lean on the open door. The unit may tip forward causing injury.
•
Always turn the unit
OFF
before adding softener salt or solutions. Before
performing routine maintenance or servicing the unit, turn the unit
OFF
and unplug
the power cord from the power source.
•
The operator should never remove the cover of the unit or insert objects through
holes or openings in the cabinetry. Doing so may damage the unit and/or pose a
hazard to the operator.
•
If the unit is used in a manner other than that specified, the protection provided by
the equipment may be impaired.
