Sakai SV410-2, Operator'S Manual

Page: 20 / 77

– 16 –
1. BASIC SAFETY PRECAUTIONS
WARNING: Negligence of these instructions can lead to accidents.
1.12 Safety Decals
Keep all decals clean. If lost, replace with new one. There are decals other than those shown
below: Treat them in the same manner as the one shown here.
3998-16504-0
･
Operate only while seated.
･
Use the handrails and steps when boarding and getting off.
･
Never carry passengers.
･
Never attempt to board or get off the machine while it
is moving.
2.Preparation for Safe Operation
･
Clean the steps, operator's station and floorboards.
･
Obey the worksite rules.
･
Sakai accepts no responsibility for any injury or damage
to the machine caused by unapproved modification.
･
Do not use a machine which needs repair or maintenance.
･
Sound the horn immediately prior to starting the engine
to warn people in the vicinity.
3.Starting the Engine
4.Parking Precautions
･
When parking the machine, park it on level ground, set
the parking switch and set the roller chocks.
･ When getting off the machine, remove the key from the
ignition switch.
･
Allow the engine to cool off by running it for about
5 minutes before stopping.
･
Check that all operating levers are in the neutral position.
･
Idle the engine for about 5 minutes to warm it up prior
to commencing work.
1.When Handling the Machine:
WARNING
①
3998-16504-0
･
Thoroughly read the operator's manual before
using the machine.
･
Incorrect operation can cause severe injury or death.
3998-16497-1
･
It is your responsibility to operate
the machine safely
WARNING
②
3998-16497-1
CALIFORNIA
Proposition 65 Warning
Diesel engine and some of its
constituents are known to the State of
California to cause cancer, birth
defects, and other reproductive harm.
3998-16489-0
④
3998-16489-0
･
Do not open the hood with the engine
running.
･
Contact with hot parts will cause burns.
3998-16499-0
･
Contact with rotating parts will cause
severe injury.
WARNING
⑤
3998-16499-0 (2 locations)
flame when radiator cap has been removed.
･
Radiator fluid is flammable. Avoid exposure to
3998-16535-0
･
Do not open the radiator cap when fluid is hot.
DANGER
3998-16536-0
･
Avoid contact with the machine parts in
the vicinity of the engine while engine
is running and after it has been stopped.
Contact with hot parts will cause burns.
DANGER
⑥
3998-16535-0
⑨
3998-16536-0
･
Do not work in the vicinity of overhanging
banks, or on grades steep enough to cause
the machine to slide or roll over.
Roll Over Prevention
･
Reduce speed prior to making turns.
･
Pay particular attention when operating on
uneven surfaces, as the machine may become
unstable.
3998-16505-0
DANGER
⑦
3998-16505-0
DANGER
Be Careful with Fire
･
When refueling, stop the engine and do not
smoke.
･
The filter cap of the fuel tank must be
kept tight.
3998-16501-0
⑩
3998-16501-0
daily prior to commencing work.
3998-16507-1
Lubricate all grease fittings
CAUTION
⑪
3998-16507-1
the vibrator case when changing oil.
3998-16510-0
Refill the specified quantity of oil in
CAUTION
⑫
3998-16510-0
When the vehicle storage for the long term, release the
parking brake and travel te vehicle for a little while.
them put the parking brake on again. Do this operation
once a mont at least.
CAUTION
PREVENT THE LOCKING OF PARKING BRAKE
3998-16468-1
⑬
3998-16468-1
⑧
3998-36002-0 (2 locations)
･
Avoid inhalation of exhaust gas.
･
Avoid contact with exhaust pipe while
engine is running and after it has been
stopped. Contact with hot exhaust pipe
will cause burns.
3998-16500-0
WARNING
③
3998-16500-0
⑭
3998-16559-0
EXPLOSIVE GASES
Cigarettes,flames or sparks could cause battery to explode.Always
shield eyes and face from battery.Do not charge or use booster cables
or adjust post connections without proper instruction and training.
KEEP VENT CAPS TIGHT AND LEVEL
Contains sulfuric acid.Avoid contact with skin,eyes or clothing.In
event of accident flush with water and call a physician immediately.
KEEP OUT OF REACH OF CHILDREN
CAUSES SEVERE BURNS
3998-16559-0
⑮
3998-06139-0
• Use of other than the specified
fuel may result in damage to
the engine.
• Please refer to the manual for
details.
2998-96001-1
USE SPECIFIED FUEL ONLY
CAUTION
⑯
2998-96001-1