Polaris 2011 RANGER RZR, Service Manual

Page: 380 / 418

10.27
ELECTRICAL
10
9923142 - 2011 RANGER RZR / RZR S / RZR 4 Service Manual
© Copyright 2010 Polaris Sales Inc.
BATTERY SERVICE
Battery Specifications
IMPORTANT: Never attempt to add electrolyte or
distilled water to a Maintenance Free battery. Doing so
will damage the case and shorten the life of the
battery.
IMPORTANT: Never attempt to open the battery. If the
seal is broken, the battery will be ruined and will fail
within a few weeks.
General Battery Information
1. Check battery voltage with a volt/ohm meter. A fully
charged battery should be 12.8 V or higher.
2. If the voltage is below 12.6 V, the battery will need to be
recharged (see “Charging Procedure”).
To service a Maintenance Free battery:
1. Remove battery from the vehicle (see Chapter 2).
2. Test battery with a voltage meter or load tester to determine
battery condition. This will determine the length of time
required to charge the battery to full capacity. Refer to OCV
table (see “OCV - Open Circuit Voltage Test”).
3. Charge the battery as recommended (see “Charging
Procedure”).
RZR / RZR S
Battery PN 4011496
Type
Polaris / Yuasa YTX20HL-BS
Sealed - Maintenance Free
Voltage 12 Vdc
Nominal Capacity @
10 HR Rate
18 AH
CCA 310
Nominal Open
Circuit Voltage
12.8 Vdc or more.
Recommended
Charging Rate
1.8A @ 5-10 HR or 9.0A @ 1 HR
ALL EPS AND RZR 4 MODELS
Battery PN 4011224
Type
Polaris / Deka ETX30L
Sealed - Maintenance Free
Voltage 12 Vdc
Nominal Capacity
@ 10 HR Rate
30 AH
CCA 365
Nominal Open
Circuit Voltage
12.8 Vdc or more.
Recommended
Charging Rate
1.8A @ 5-10 HR or 6.0A @ 1 HR
WARNING
CALIFORNIA PROPOSITION 65 WARNING:
Batteries, battery posts, terminals and related
accessories contain lead and lead compounds, and
other chemicals known to the State of California to
cause cancer and birth defects or other reproductive
harm. WASH HANDS AFTER HANDLING.
WARNING
Battery electrolyte is poisonous. It contains acid!
Serious burns can result from contact with the skin,
eyes, or clothing.
ANTIDOTE:
External: Flush with water.
Internal: Drink large quantities of water or milk. Follow
with milk of magnesia, beaten egg, or vegetable oil.
Call a physician immediately.
Eyes: Flush with water for 15 minutes and get prompt
medical attention.
Batteries produce explosive gases. Keep sparks,
flame, cigarettes, etc. away. Ventilate when charging
or using in closed space. Always shield eyes when
working near batteries.
Keep out of reach of children.