Nilfisk-Advance Cr 1100, Quick Start Troubleshooting Manual

Page: 16 / 83

14 - FORM NO. 56043126 - CR 1100, CR 1200
1 Operator’s Seat – Operator sits here. Seat is adjustable forward and back.
2 Strobe Light (optional / standard on Nil fi sk models) – This light starts fl ashing when the ignition switch is turned ON.
3 Solution Tank Fill – Open to fi ll the solution tank, use non-foaming chemicals only. 75 gallon (284 liter) maximum capacity.
4 Tie down Locations – Safe point to tie down machine while transporting.
5 Recovery Tank Drain Hose – Used to empty the recovery tank (hold the end of the hose above the water level in the tank to avoid sudden,
uncontrolled fl ow of waste water).
6 Recovery Tank Latch – Push down on latch lever to release recovery tank for “Tip-Out” feature.
7 Left Battery Compartment Access Panel – Panel lifts straight up after opening Battery Compartment Door (21) to provide access to the
battery compartment from the left side of the machine. SERVICE NOTE: Battery can only be removed from this side.
8 Main Broom Left Access Door – Open to access main broom for servicing.
9 Hopper Cover Prop Rod – Used to support the hopper cover while raised.
10 Front Wheel – Machine front wheel.
11 Jacking Location – Safe points for jacking machine up. DO NOT jack the machine on the hopper.
12 Left Side Broom – Used for sweeping along walls or curbs.
13 Hopper Cover Latch – Holds Hopper Cover (16) in place.
14 Headlights – Use when sweeping in hard to see areas.
15 Right Side Broom – Used for sweeping along walls or curbs.
16 Hopper Cover – Open to access the hopper dust control fi lter.
17 Dust Control Filter – Filters dust from the air.
18 Dust Control Shaker Assembly – Vibrates the Dust Control Filter (17) to shake dust out of it.
19 Shaker Assembly Latch – Used to hold the Shaker Assembly (18) UP while servicing the fi lter.
20 Battery – Provides electrical power for operating the machine.
21 Battery Compartment Door – Unlatch and open to access battery compartment.
22 Steering Wheel – Used to steer machine left or right.
23 Electrical Compartment Door – Open this door to access the main controller and solenoids. DO NOT open this door unless the Emergency
Battery Disconnect (KK) has been pushed IN.
24 Water Level Gauge – When fi lling the solution tank do not exceed the maximum level.
25 Recovery Tank Lid – Open to rinse and clean inside of recovery tank.
26 Recovery Tank “Tip-Out” Grip – Grab and pull here after unlatching to tip the recovery tank out to the side for cleaning.
27 Hydraulic Power Unit (Reservoir / Filter) – Holds the hydraulic system oil, 1.7 quart (1.6 liter) capacity. SERVICE NOTE: Open and prop
the hopper to add oil. Hydraulic return oil fi lter on side of the unit fi lters oil after fl owing through system and prior to returning to reservoir.
28 Right Battery Compartment Access Panel – Panel lifts straight up after opening Battery Compartment Door (21) to provide access to the
battery compartment from the Right side of the machine.
29 Main Broom Right Access Door – Open to access main broom for servicing.
30 Access Door Latch – Push UP on lever to unlatch (Recovery Tank utilizes same latch for “Tip-Out” feature).
31 Skirt Assembly – Scrub system has left and right skirt assemblies to channel solution on fl oor into the path of the squeegee assembly.
32 Inline Solution Filter – Filters solution prior to dispensing on fl oor.
33 Solution Tank Drain Hose – Used to empty the solution tank.
34 Rear Roller Bumper – Protects both machine and other objects in the event the machine brushes up against anything.
35 Squeegee Handle – Loosen these two handles to remove the squeegee assembly from the machine.
36 Squeegee Assembly – Picks up solution after scrubbing.
37 Tail Light – Turns ON with headlights.
KNOW YOUR MACHINE DESCRIPTIONS