4
18
_
00
ED0053031100
INFORMATION ABOUT USE
EN
•
Read carefully the following pages and carry out the
operations described below in accordance with the
instructions specified.
Important
•
Non compliance with the operations described in the following
pages involves the risk of damages to the engine and vehicle
on which it is installed as well as personal and/or property
damage.
4.1
Pre-start check
•
Increase the frequency of maintenance operations in heavy
working conditions (engine starts but stops, very dusty and
hot environments, etc...).
4.2
Break-in running
NOTE:
For the first 50 hours of engine operation, it is advisable not to exceed 75% of the maximum power supplied.
4.3 Starting and turning off
4.3.1 Starting
1 -
Check the level of the engine oil, fuel and coolant and fill if
necessary (
Par. 4.5 and Par. 4.6
).
2 -
Put the ignition key in the ignition switch.
3 -
Tun the key to
1
position.
4 -
Press the
Start
push button for it to start automatically.
Important
•
RPM reading delay is normal.
•
If engine does not start after two attempts see
Tab. 7.1
and
Tab. 7.2
to found the cause.
4.3.2 After starting
Warning
•
Make sure that all the warning lights on the control panel are off when the engine is running.
•
Check for any leakages from the pipes on first start-up
1 -
Run at minimum speed for a few minutes according to table.
AMBIENT TEMPERATURE
TIME
≤ -20°C
2 minutes
from
-20° C
to
-10°C
1 minutes
from
-10° C
to
-5° C
30 seconds
from
-5° C
to
5° C
20 seconds
≥ 5° C
15 seconds
4.3.3 Turning off
1 -
Do not turn off the engine with a full load or when it is running at the maximum rotation speed. Leave it running at idle speed
without a load for approximately 1 minute.
2 -
Press the
Stop
push button (the engine turns off) and turn the key to position
0
.
Summary of Contents for KDI 2504 M-MP
