Instruction Manual
SMART-LIFT Electric Ceiling Lifts
3
PRETEST THE LIFT BEFORE INSTALLING
IMPORTANT:
Before mounting the lift in the ceiling, make
the following tests to be sure that it operates properly and has
not been damaged in shipping.
1.
Carefully inspect the lift for shipping damage. If any
damage is apparent, call your carrier claims agent and do
not continue with the installation until the carrier has
reviewed the damage.
2.
Set the lift upside down on a clean, level surface.
NOTE:
The lift is supplied with a momentary push button
on the end of a cable to help you pretest the operation.
3.
Connect the momentary push button cable’s leads to ter-
minals #6 and #1 and add a jumper wire (electrical wire
about 4 in. long with 1/4 in. stripped at each end)
between terminals #2 and #5 on the same terminal block
(see Fig. 1, Item P).
4.
Plug the lift’s power cord into a 110V 60 Hz or 220V 50
Hz (as appropriate) 15-amp outlet.
NOTE:
The lift draws approximately 1.5 amps.
5.
Operate the lift much like a garage-door opener: press
the button when the lift is at its “top” position and it will
move “down”; press again when it is at its “bottom” posi-
tion and it will move “up”; press while moving and it will
stop.
Use the push button to check that the lift runs to the top
and bottom of its travel without any interference that
might indicate damage during shipment.
6.
Unplug the lift’s power cord.
A. Lift Housing — Mounting Assembly
B. Cradle — Yaw/Pitch/Roll Assembly
C. Drop Carriage — Ceiling Pan Assembly
D. Carriage Guide Rod
E. Drive Motor Assembly
F. Drive Motor Support Brackets
G. Drive Chain
H. Idler Sprockets
J. Drive Axle Assembly
K. Support Chains
L. Sprocket Support — Chain Tightener
Bracket Assembly
M. Controller
N. Controller Housing
P. External Control Terminal Block
Q. Internal Control Terminal Block
R. Power Input, 110V
S. Internal Power Junction, 110V
A
B
C
D
E
F
G
H
J
K
L
M, N
P
R
S
Figure 1. Smart Lift Parts
Q
Summary of Contents for SL-100
