51
0.130 in. (3.3 mm)
0.181 in. (4.6 mm)
6 CELL
50TM400484
8 CELL
50TM400485
10 CELL
50TM400439
IGNITER AND SENSOR LOCATIONS
(BRACKET HEAT COVER NOT SHOWN FOR CLARITY)
SEE DETAIL A
SEE DETAIL A
SEE
DETAIL A
DETAIL
A
C12593
Fig. 67 -- Spark Adjustment ( Size 16)
PLASTIC ADJUST
SCREW
PLASTIC ADJUST
SCREW (2)
REGULATOR SPRING
(PROPANE - WHITE
NATURAL - SILVER)
REGULATOR SPRING (2)
(PROPANE - WHITE
NATURAL - SILVER)
GAS PRESSURE
REGULATOR
ADJUSTMENT
LOW STAGE
GAS PRESSURE
REGULATOR
ADJUSTMENT
MANIFOLD
PRESSURE TAP
MANIFOLD
PRESSURE TAP
NPT OUTLET
NPT OUTLET
INLET
PRESSURE TAP
INLET
PRESSURE TAP
ON/OFF
SWITCH
ON/OFF
SWITCH
REGULATOR
COVER SCREW
REGULATOR
COVER SCREW (2)
NPT INLET
NPT OUTLET
NPT INLET
2 STAGE
SINGLE STAGE
NPT OUTLET
C12066
Fig. 68 -- Gas Valves
Table 14 – LED Error Code Description*
LED INDICATION
ERROR CODE DESCRIPTION
ON
Normal Operation
OFF
Hardware Failure
1 Flash
{
Evaporator Fan On/Off Delay Modified
2 Flashes
Limit Switch Fault
3 Flashes
Flame Sense Fault
4 Flashes
4 Consecutive Limit Switch Faults
5 Flashes
Ignition Lockout Fault
6 Flashes
Induced---Draft Motor Fault
7 Flashes
Rollout Switch Fault
8 Flashes
Internal Control Fault
9 Flashes
Software Lockout
LEGEND
LED --- Light Emitting Diode
* A 3---second pause exists between LED error code flashes. If
.
more than one error code exists, all applicable codes will be
displayed in numerical sequence.
{
Indicates a code that is not an error. The unit will continue to
operate when this code is displayed.
IMPORTANT
: Refer to Troubleshooting Table 24 and
Table 25 for additional information.
Orifice Replacement
This unit uses orifice type LH32RFnnn (where nnn
indicates orifice reference size). When replacing unit
orifices, order the necessary parts through Carrier RCD.
See Table 16 for available orifice sizes. See Table 17
through Table 20 for orifice sizes for Natural Gas and LP
fuel usage at various elevations above sea level.
Check that each replacement orifice is tight at its threads
into the manifold pipe and that orifice projection does not
exceed maximum value. See Fig. 62.
48TC
Summary of Contents for 48TC 04 Series
