Capacity TJ5000 DOT, Operator'S Handbook Manual

Page: 46 / 116

Capacity of Texas, Inc.
38
4-3.6 1000-H
OUR
M
AINTENANCE
The following checks should be made after every 1000 hours of
operation.
• Change internal transmission filter and change fluid. (Oil
sampling analysis recommended)
• Change steer reservoir filter and fluid.
• Change hydraulic oil and clean strainer.
• Check drive belt, cooling fan, cooling fan belt tensioner
• Check air dryer cartridge.
• Check and adjust fifth wheel jams
• Change cab tilt oil.
• Test fuel injection nozzles - Manufacturer Repair Facility
• Check and clean automatic drain on wet air tank.
• Check Dura-Ride center bearing
• Check Dura-Ride air bags
• Check Dura-Ride height adjustment
4-3.7 2000-H
OUR
M
AINTENANCE
The following checks should be made after every 2000 hours of
operation.
• Flush cooling system
• Check viscous vibration damper
• Steam clean engine
• Check radiator hoses
• Inspect crankcase ventilation filter. Replace if necessary.
4-3.8 O
VERHEAD
S
ET
A
DJUSTMENT
Overhead set adjustment should be performed at 5000 hours
or 4 years of operation.
4-3.9 T
HREE
-Y
EAR
/ 6000 H
OUR
C
HECKS
The following checks should be made every three years or
after every 6000 hours of operation. Capacity recommends a
preventive overhaul be performed by an authorized repair
facility.
• Change oil in rear axle
• Change oil in wheel bearings