wsm wg972-e4, Руководство по ремонту

Страница: 38 / 153

GENERAL
WG972-E4, WSM
G-12
Checking and Filling Radiator Coolant
1. Without recovery tank:
Remove the radiator cap (1) and check to see that the coolant
level is just below the port.
With recovery tank (2):
Check to see that the coolant level lies between
FULL "A" and
LOW "B" .
2. If coolant level is too low, check the reason for decreasing
coolant.
(Case 1)
If coolant is decreasing by evaporation, fill only fresh, soft water.
(Case 2)
If coolant is decreasing by leak, fill coolant of the same
manufacture and type in the specified mixture ratio (fresh, soft
water and L.L.C.). If the coolant brand cannot be identified,
drain out all of the remaining coolant and refill with a totally new
brand of coolant mix.
CAUTION
• Do not remove the radiator cap until coolant temperature is
below its boiling point. Then loosen the cap slightly to
relieve any excess pressure before removing the cap
completely.
IMPORTANT
• During filling the coolant, air must be vented from the
engine coolant passages. The air vents by jiggling the
radiator upper and lower hoses.
• Be sure to close the radiator cap securely. If the cap is
loose or improperly closed, coolant may leak out and the
engine could overheat.
• Do not use an antifreeze and scale inhibitor at the same
time.
• Never mix the different type or brand of L.L.C..
9Y1211108GEG0016US0
Checking Air Cleaner Element (If Necessary)
1. Remove the cover (2) and the primary element (4) in the air
cleaner.
2. Check the dust in the cover (2), the primary (4) and secondary
(3) element.
3. If the primary element (4) is stained, clean it.
(When reassembling)
• Install the air cleaner dust cup with "TOP" indicated on the rear
of the cup.
NOTE
• Avoid touching the element except when cleaning.
• The air cleaner uses a dry element, never apply oil.
• Do not operate the engine with filter element removed.
• Do not touch the secondary element (3) except in cases
replacing is required.
9Y1211108GEG0017US0
(1) Radiator Cap
(2) Recovery Tank A: FULL
B: LOW
(1) Air cleaner body
(2) Cover
(3) Secondary element (4) Primary element
(5) Evacuator valve
KiSC issued 07, 2015 A