Western LOW-PRO 300W, Руководство механика

Страница: 11 / 106

Lit. No. 72131, Rev. 00 July 15, 2018
9
SAFETY
CAUTION
Read instructions before assembling.
Fasteners should be
fi nger tight until
instructed to tighten according to torque
chart. Use standard methods and practices
when attaching spreader, including proper
personal protective safety equipment.
1/4-20 109 154
1/4-28 121 171
5/16-18 150 212
5/16-24 170 240
3/8-16 269 376
3/8-24 297 420
7/16-14 429 606
7/16-20
9/16-12
9/16-18
5/8-11
5/8-18
3/4-10
3/4-16
7/8-9
7/8-14 474 669
644 909 1-8
1-12 704 995
1/2-13
1/2-20
11.9
13.7
24.6
27.3
43.6
26.9
53.3
93
148
49.4
69.8
77.9
106.4
120.0
8.4
9.7
17.4
19.2
30.8
35.0
49.4
55.2
75.3
85.0
M6 x 1.00
M12 x 1.75
M8 x 1.25
M14 x 2.00
M10 x 1.50
M27 x 3.00
M22 x 2.50
M30 x 3.50
M24 x 3.00
M20 x 2.50 11.1
19.5
38.5
67
107
7.7
613
778
1139
1545
450
428
562
796
1117
M33 x 3.50
M36 x 4.00 2101
2701 1468
1952
325
M16 x 2.00 231 167
M18 x 2.50 318 222
Recommended Fastener Torque Chart
Size Size
Torque (ft-lb)
Grade
5
Grade
8
Metric Fasteners Class 8.8 and 10.9
These torque values apply to fasteners
except those noted in the instructions.
Torque (ft-lb)
Grade
5
Grade
8
Size Size
Torque (ft-lb)
Class
8.8
Class
10.9
Torque (ft-lb)
Class
8.8
Class
10.9
Inch Fasteners Grade 5 and Grade 8
BATTERY SAFETY
NOISE
Airborne noise emission during use is below
70 dB(A) for the spreader operator.
VIBRATION
Operating spreader vibration does not exceed
2.5 m/s
2
to the hand-arm or 0.5 m/s
2
to the whole
body.
CAUTION
Batteries normally produce explosive
gases, which can cause personal injury.
Therefore, do not allow
fl ames, sparks, or
lit tobacco to come near the battery. When
charging or working near a battery, always
cover your face and protect your eyes, and
also provide ventilation.
• Batteries contain sulfuric acid, which
burns skin, eyes, and clothing.
• Disconnect the battery before removing
or replacing any electrical components.
REAR VISION SYSTEMS
The National Highway Traf fi c Safety Administration
(NHTSA) has set new rear vision system
requirements for vehicles with a 10,000 lb or lower
Gross Vehicle Weight Rating (GVWR) in an update
to the Federal Motor Vehicle Safety Standard
(FMVSS) No. 111. It requires that vehicles with a
rear vision system still have unobstructed use of
that system (or an equivalent replacement) after
the vehicle is altered. NHTSA offers information on
this standard and testing procedures to verify that
auxiliary systems meet the standard on its website.
It is the responsibility of the installer to verify that
the vehicle complies with FMVSS.
WARNING
Vehicles <10,000 lb GVWR: Obstructing
the visibility from the vehicle's rear camera
could result in serious injury or damage.
An auxiliary camera system shall be
installed if the vehicle's rear camera is
removed or blocked.
TORQUE CHART