Mazda 626 1989, Руководство по ремонту

Страница: 530 / 768

Number: 006/93
Date Issued: 2/12/93 Date Revised: 8/17/92
INSPECTION AND REPAIR PROCEDURE (CONT’D)
4. Check that the drain hoses are attached to the sunroof drain tubes. Replace hose(s) as necessary. Check for kinks
at the drain hose clip. Figure 31.
C A U T IO N :U SE CARE WHEN PULLING THE HEADLINER DO W N. IF IT IS PULLED TOO FAR, THE
HEADLINER WILL BE PERMANENTLY DETACHED FROM THE HIDDEN BRACKET.
5. Check if welds around the rear sunroof drain tubes are intact and drain properly. With the sunroof closed, direct
water over the sunroof and check for leaks at the drain tubes. If the welds are damaged or have holes, repair or
replace the sunroof frame.
W A R R A N T Y IN FO R M A TIO N
(Applies to vehicles covered under warranty.)
Warranty Type Code:
Customer Comment Code:
Dam age Code:
Part N o. o f Main Cause:
Operation No.:
Labor Hours:
Location Code:
A
77
9K
5555 WA 001
See Chart Below.
See Chart Below.
Applicable location code necessary. Codes found in SRT microfiche or Warranty
Policies and Procedures Manual.
P R O C E D U R E
O PE R A T IO N N U M B E R L A B O R H O U R S
Water Testing Y Y 0064R X 0.5
Repair o f Right Front Side of
Passenger Compartment
Y Y 0033R X Not to exceed 0.9 Hrs.
Repair o f Left Front Side of
Passenger Compartment
Y Y 0034R X Not to exceed 0.9 Hrs.
Repair o f Trunk Compartment
and Under Rear Seat
Y Y 0035R X Not to excecd 0.9 Hrs.
Repair o f Sunroof or
Headliner Area
Y Y 0036R X
Not to exceed 0.9 Hrs.
N O T E : - Water testing and labor hours for each area are not to exceed four (4) entries.
- Enter each area o f water entry as a separate problem. Each problem should have a different
location code.
- Subsequent repairs to the same area will be denied.
Page 15 o f 15