Mazda 626 1989, Руководство по ремонту, Страница: 3 / 768

0 PRE-DELSVERY
SNSPECTION
PRE-DELIVERY INSPECTION
PRE-DELIVERY INSPECTION TABLE
EXTERIOR
INSPECT and ADJUST, if necessary, the following items to
the specifications:
□ Glass, exterior bright metal and paint for damage
□ Wheel lug nuts
8 8 - 1 1 8 N-m ( 9 - 1 2 m-kg, 6 5 - 8 7 ft-lb)
□ Tire pressures (Refer to section 12)
□ All weatherstrips for damage or detachment
□ Operation of hood release and lock
□ Operation of fuel lid and trunk lid (Back door) opener
□ Door operation and alignment
□ Headlight aiming
INSTALL following parts:
□ Wheel caps or rings (if equipped)
□ Outside rear view mirror(s)
"UN DER HOOD— ENGINE OFF
INSPECT and ADJUST, if necessary, the following items to
the specifications:
□ Fuel, coolant and hydraulic lines, fittings, connections and
components for leaks
□ Engine oi! level
□ Power steering fluid level (if equipped)
□ Brake and clutch master cylinder fluid level (if equipped)
□ Windshield washer reservoir fluid level
□ Radiator coolant level and specific gravity
Protection °C (°F) Specific gravity at 20°C (68°F)
- 1 6 ( 3 ) 1.054
- 2 6 (-1 5 ) 1.066
- 4 0 (-4 0 ) 1.078
□ Tightness of water hose clamps (including heater hoses)
□ Tightness of battery terminals
□ Manual transaxle oil level
□ Drive belt tensions (Refer to section 1)
□ Accelerator cable and its linkage for free movement
□ Headlight cleaner fluid level (if equipped)
CLEAN spark plugs
INTERIOR
IN S TA LL the following parts:
□ Rubber stopper for inside rear view mirror
□ Fuse for accessories •
CHECK the operations of the following items:
□ Seat controls (sliding and reclining) and head rest
□ Door locks including childproof door locks (if equipped)
□ Seat belts and warning system
□ Ignition switch and steering lock
□ Inhibitor switch (ATX only)
□ All lights including warning and indicator lights
□ Sound warning system
□ Headlight cleaner (if equipped)
□ Horn, wipers and washers (front and rear, if equipped)
□ Radio and antenna (if equipped)
□ Cigarette lighter and clock
□ Remote control outside rear view mirrors (if equipped)
□ Power windows (if equipped)
□ Heater, defroster and air conditioner at various mode selec­
tion (if equipped)
□ Sunroof (if equipped)
A D JU S T antenna trimmer on radio (if equipped)
CHECK the following items:
□ Presence of spare fuse
□ Upholstery and interior finish
CHECK and ADJU ST, if necessary, the following items:
□ Operation and fit of windows
□ Pedal height and free play of brake and clutch pedal
Pedal height mm (in) free play mm (in)
Clutch pedal 216.5-217 (8.52-8.54) 5— 13 (0.2—0.51)
Brake pedal 222-227 (8.74-8.94) 4 - 7 (0 .1 6 -0 .2 8 )
□ Parking brake
5 - 7 noches/98 N (10 kg, 22lb)
UNDER HOOD—ENGINE RUNNING AT
OPERATING TEM PERATUR E_________
CHECK the following items:
□ Automatic transaxle fluid level
□ Initial ignition timing
Non-turbo 6 ° ± 1° BTDC
Turbo 9 ° ± 1° BTDC (with test connector grounded)
ON H O IS T "
CHECK the following items:
□ Underside fuel, coolant and hydraulic lines, fittings, connec­
tions and components for leaks
□ Tires for cuts or bruises
□ Steering linkage, suspension, exhaust system and all under­
side hardware for looseness or damage
REMOVE protective cover from brake discs
ROAD T E S T "
CHECK the following items:
□ Brake operation
□ Clutch operation
□ Steering control
□ Operation of meters and gauge
□ Squeaks, rattles or unusual noise
□ Engine general performance (including turbo)
□ Emergency locking retractors
□ Cruise control system (if equipped)
AFTER ROAD TEST
REMOVE seat and floor mat protective covers
CHECK for necessary owner information materials, tools and
spare tire in vehicle
86U00X-002
0 - 2