Jacobsen Truckster XD, Руководство по эксплуатации и техническому обслуживанию

Страница: 65 / 76

MAINTENANCE 9
en-64
9.18 TRANSMISSION FLUID LEVEL _______________________________________________
Check the transmission fluid level each 100 hours.
a Remove fluid level plug from the left side of the transmission
adapter on the rear axle.
b The transmission fluid level must at the bottom of the fluid
level plug. Add SAE EP 80-90 Gear Lube when necessary.
c Install the fluid level plug.
Drain and replace the transmission fluid each year or 600 hours,
that occurs first.
a Clean the area around the transmission drain plug to prevent
dirt to enter the transmission.
b Put a container that can hold more than 1 U.S. gallons (3.8
liter) below the transmission and the rear axle. Remove the
drain plug from the bottom of the transmission adapter and
allow the transmission fluid to drain into the container.
c After the oil has drained, install the drain plug. Torque the drain plug to 9-14 ft. lb. (12-19 Nm).
d Remove the fluid level plug and fill the transmission with SAE EP 80-90 Gear Lube to the bottom of the level plug.
Install the level plug. Torque the level plug to 9-14 ft. lb. (12-19 Nm).
9.19 ELECTRICAL SYSTEM _____________________________________________________
General precautions to decrease electrical problems are -
• Make sure that all the connections are clean and correctly fastened.
• Check the interlock system and fuses at normal intervals. If the interlock system does not operate correctly and
you can not correct the problem, contact an authorized Jacobsen Dealer.
• Keep the wiring harness away from hot surfaces and moving parts.
• Check the battery and the alternator.
• Do not wash or pressure spray around electrical connections and components.
Two in-line fuses are found in the positive battery cable. The 60 amp fuse gives protection for the alternator. The 175
amp fuse gives protection for the vehicle circuits.
Fuses and relays found behind the dashboard are used to protect the vehicle circuits.
If accessories are installed, additional fuses and relays may be located near the fuse panel.
CAUTION
Always turn the ignition switch to the off position and remove the negative (BLACK) battery cable before you inspect
or service the electrical system.
Fluid Level
Plug
Drain Plug
Fluid Level
!