Epoke SKE Series, Инструкция по эксплуатации

Страница: 6 / 29

4
epoke
®
SKE8-12-15-20
GB-0305.1
epoke
®
2 Descriptions
2.0.0 General
Important instructions are highlighted in each section.
Explanations of symbols
Warning
(Work safety signal)
Safety should be observed where this sign is
positioned. Pay attention to this safety informa-
tion sign and follow it be careful. Always follow
the general safety regulations as well.
Information
In the instructions for use, this symbol is placed
next to all important information relating to opera-
tion or the equipment’s function.
Later on, these symbols will be used for visual registration
of danger information signs.
2.0.1 Transport and handling
2.0.1.1 Transport
During transport, empty the solids tank and the loosen
spring base adjustment on the spreader.
Danger!
Road-users may be seriously injured, e.g. due
to projec-ting parts, loss of the spreader, etc.!
The spreader should be properly fastened.
Information!
• The spreader should only be put down on a level surface.
• The spreader should be adequately secured on the car-
rying vehicle.
• Electrical parts should be protected against humidity.
2.0.1.2 Handling
A crane must be used at all times when trans-
porting or using the spreader. The spreader sho-
uld be raised using the fastening rings.
Note the lifting tackle’s load capacity and the spreader’s
centre of gravity!
People can be seriously injured - e.g. through crushing!
2.0.1.6 Rules for total weight of towed vehicles
The total weight of the towed vehicle must never
exceed the weight limits stated by the manufacturer
of the vehicle/towbar.
In the case of cars, the weight limit may be found on the
manufacturer’s label on the car or in the user manual.
2.0.2 Information on restrictions on use
2.0.2.1 Normal use
Machines for winter service are machines for
removing winter obstacles in traffic areas, and
spreaders are machines for defined spreading
of thawing materials or sand on surfaces car-
rying traffic.
The spreaders must only be used for the purpose for
which they are intended. The spreaders must only be
operated, repaired and maintained by persons who are
fully familiar with these areas. These persons shall also
be informed about the dangers which the spreader can
pose.
Note
- Only persons who are physically and psychologi-
cally suitable, and who are familiar with the content of the
operating instructions, may use the machine.
The user shall comply with the references in the operating
instructions.
Note - The manufacturer’s liability for any damage that may
occur shall lapse in the event of any form of abnormal use.
2.0.2.2 Abnormal use
Abnormal use
• when the spreaders are not used as spreaders
for winter service, and when the spreader has
not been mounted and connected correctly to
the towing vehicle.
• when the spreader is used for spreading materials which
are not used for combating icy roads.
• when the spreader is towed using an unsuitable vehicle
without taking into account the weight limits imposed by
the manufacturer of the vehicle. (trailer spreader only).
2.0.3 Hazards presented by the machine
2.0.3.1 Personal protective measures
As the design and construction ensure that the
operator's freedom of movement is not reduced,
use of personal protective measures (shoes, glo-
ves etc.) is not required.
2.0.3.2 Mechanical hazard
There is a risk of injury and damage from squas-
hing, cutting and from sharp edges. To the extent
possible, points on machines that present such
hazards are fitted with protective devices.
2.0.3.3 Electrical hazard
• Work on the power supply must only be carried
out by an expert electrician.
• Loose connections and burnt-out cables must
be replaced immediately.
• Use only original fuses.