66
VW will not start:
engine turns over
8. If spark is fairly good at plugs,
trouble is most likely in fuel
system
A. Caused by improper starting
procedure. If the gas pedal
is depressed too often, the
carburetor accelerator
pumps inject too much
gasoline
B. Carburetors may be flooded,
float or needle valve may
be sticking
Problem
Probable Cause
What To Do
8. Check fuel system in the following sequence:
A. Depress gas pedal completely and operate starter for a prolonged period.
If engine does not start, remove and dry spark plugs, turn over engine with
plugs removed for approximately 30 seconds. Reinstall plugs and start
engine
B. Tap around outside of carburetor with wooden or plastic tool handle. Wait
a few minutes and try starting again as described at 8 A
Engine stalls shortly
after starting
Engine stalls while
vehicle is driven
Red warning light for
oil pressure comes
on while you are
driving
Red warning light for
alternator comes on
while you are driving
9. Poor fuel supply
10. Automatic chokes do not open,
excessive fuel supply
11. Defect in ignition system
12. Fuel supply is exhausted
13. Gasoline may be contaminated
by water, dust or dirt
14. If light goes on, the oil pres-
sure is too low
9. See paragraph 12 and 13
10. Check whether choke valves are in vertical position after ignition has been
switched on for 2-5 minutes (depending on outside temperatures). Covers for
choke units must be hot. If choke valves are binding in a closed position, open
at fast idle cam and if necessary, retain with wire.
11. See paragraphs 5 through 7
12. Check whether any gasoline is left in tank
13. See your VW dealer for cleaning of all components of the fuel system
14. Stop at once and check oil level. Add oil as necessary. If the oil level is
sufficient and light goes and during driving, contact the nearest Authorized VW
Dealer before driving on
15. If light goes on, V-belt may be
torn or alternator does not
charge
15. If belt drives alternator without slipping, switch off all unnecessary electrical
equipment (radio, etc.). Drive to nearest VW dealer as otherwise the battery
will soon run down
