Operation & Maintenance Manual
CD-135 / CD-155
OM-02-02
Revision no.:
Revision date:
Chapter:
Issue:
Issue date:
Page:
Content:
02-OM-06-02
4
30.07.2014
5
74
7
20.07.2016
•
Exchange gearbox oil and the gearbox oil filter (refer to
Annex 13, Page 52 of this Chapter);
A sample of the oil and the used gearbox oil filter should be
labeled, stored in a clean container and made available to
Technify Motors GmbH on request for the complete engine
life time. The sample will be required for later long-run
analysis. The label must show the aircraft serial number,
registration number, engine serial number, operation time
and date.
Quantity of oil to be taken for sample: 100ml
•
Check the presetting of the proportional pressure reducing
valve (refer to RM-02-02, Chapter 72-10.05 or
Chapter 72-10.16)
6.2.3
Every 200 operating hours
•
Carry out all steps described in Section 6.2.2, Page 4 of this
Chapter
•
Replace air filter
6.2.4
Every 300 operating hours
•
Carry out all steps described in Section 6.2.2, Page 4 of this
Chapter
•
Replace clutch, if clutch assy 05-7211-K006001 or
05-7211-K006002 is installed (refer to RM-02-02,
Chapter 72-10.02)
•
Inspect gearbox (refer to Annex 15, Page 66 of this
Chapter)
•
Inspect fuel feed pump,
except 05-7312-K0073xx, 05-7312-K0133xx
(refer to Chapter 6, Annex 18, Page 74 of this Manual)
•
Replace high-pressure pump (refer to Annex 11, Page 50 of
this Chapter)
Note:
When replacing the air filter check carefully that no foreign
objects are in it.
Note:
Replacement of the high-pressure pump at every 300 operating
hours is only applicable if TS-1 jet fuel is being used.
