Paslode IMPULSE IM90i, Manual

Page: 13 / 27

timber.
Do not drive fasteners into knots or on top of other
fasteners. Never drive fasteners into areas with concealed
hazards.
The temperature of the tool may increase depending
on firing frequency. Observe the cycle rates given in the
operating instructions: 2 to 3 nails per second, 1000 nails
per hour.
The condition of the tool should be checked at least
once a year by the manufacturer or an authorized agent.
We recommend that you carry out regular maintenance
(cleaning and lubrication) to keep the tool in good working
order.
It is not permitted to make any modification to the
tool, fuel cell or battery other than those specified by the
manufacturer.
FUEL CELL
The fuel cell is an aerosol product corresponding to the
75/324/EEC and TRG 300 regulations. It contains:
- Liquefied hydrocarbon gases(butane,propane,propylene)
- A lubricant to maximize the tool durability.
When the fuel is used there will always be some propellant
left inside the cartridge. The fuel cell is always pressurized.
Its
contents are extremely flammable . The fuel cell is not
reusable. Do not attempt to refill.
Do not spray towards a flame or an incandescent body.
Keep away from any heat sources and from electrostatic
charges. Do not smoke.
Do not expose to temperatures exceeding
50°C.
Warning: liquid gas can cause injury in the event of
contact with the skin or eyes.
Store and use the cartridge in a well-ventilated area
only. Do not inhale.
Do not pierce or burn the cartridge after use.
Keep away from children.
Dispose of only in designated places.
For optimum performance, use before the date
indicated under the cartridge.
TRANSPORT
Transport of small amounts (< 30 Kg) in a private vehicle is
permitted without a transport and safety sheet. Below are the
regulations by transport categories:
- Road/rail: ADR – RID - UN code 1950 class 2 code 5F
- Sea: IMDG – UN code 1950 + risk sheet F-D,S-U class 2
- Air: IATA – UN code 1950 class 2.1
Goods must be accompanied by transport emergency card for
road UN 1950
Transport by post is not permitted
STORAGE
Stores and showrooms must comply with building
regulations. All local instructions corresponding to fire
regulations must be observed.
Where possible, store fuel at a stable temperature
in the range: 5 to 25°C. Do not expose to a temperature
exceeding 50°C. Do not use tools that emit flames, sparks
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
or reach high temperatures near to the cartridges.
Do not store in passageways and entrance halls and
near to doorways.
Store in a well-ventilated area. Fuel cells must not be
displayed in shop windows.
Storage with pyrotechnic products is not permitted.
FIRST AID
Direct contact with liquid gas may cause burns or
frostbite.
When inhaling gas, bring the person outside and put
him in a comfortable position.
When someone is unconscious, put him on his side and
when respiration stops, start to reanimat
When in contact with eyes, clean the eyes streaming
water while the eye is open.
When in contact with the skin, wash the skin with soap
and water.
If necessary, call a doctor.
BATTERY AND BATTERY CHARGER
Before using the battery charging
system, read the instructions and
precautions shown on the AC/DC
adapter, the charger and the battery
carefully.
The adapter, charger and battery are designed to
operate together as a system. Only use the ‘Paslode Impulse’
charger for ‘Paslode Impulse’ batteries.
The charging system is designed for use in covered
areas. Do not expose it to rain or to excessive humidity.
Arrange the charger lead appropriately to avoid
unnecessary damage it. Do not use the system if the cable
or plug is damaged. Replace immediately.
To avoid electrocution risk, disconnect the power
supply adapter before cleaning the terminals and contacts.
Use a dry cloth.
Do not short-circuit a battery. A high current could be
produced causing overheating and damage the battery.
Do not put a battery on charge if its temperature is
less than 5°C or greater than 40°C. Do not use a battery
charger which heats up excessively or gives off fumes when
connected. Disconnect the charger immediately.
Do not pierce or open the battery’s cells.
Do not store batteries at a temperature above 50°C.
Do not incinerate batteries.
Only charge one battery at a time on a charger.
Batteries and charging systems must be recycled or
taken to a designated disposal area (collection containers
according to local provisions).
Keep away from children.
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
GB
2