32
Figure 43 – Cable Configurations: C12, C03, C04 and C70
8.
Connect the 6-pin Shroud on
C04
to 6-pin
Tower on the junction cable (
C12
) (
Figure
43
).
9.
Connect the 6-pin Tower on the valve cable
(
C03
) to 6-pin Shroud on
C12
.
10.
C12
and
C70
have screw terminals. They
must be connected to the frame of the
sprayer Scrape any paint off the frame where
the terminal is mounted. A good location is
the bolt holding the JD wiring harness next
to the large connector at the rear of the
sprayer frame.
The terminal must be attached
directly to the sprayer frame NOT
the parallel linkage. An improper
ground can cause UC4+ Spray Height
Control malfunctions.
11.
Insert the connectors labeled
Main Up
and
Main Down
on
C12
into the main lift
connectors on the John Deere solenoids
(
Figure 44
).
12.
Insert the other connectors on
C12
into the
tilt connectors on the John Deere solenoids
(
Figure 44
).
There is one set of different connectors
(M14 and M15) included with the interface
cable (C12). Some John Deere sprayers
use this connector on the left down
function. If your sprayer has this
connector, remove the existing NORAC
connectors using the included pin removal
tool. Insert the wires into the new
connector and ensure they are in the
same position as they were in the
previous connector.
Summary of Contents for UC4+
