DIS185SSI4F AIR COMPRESSOR — HOSE REEL INSTALLATION INSTRUCTIONS P/N EE60468 — REV. #0 (04/16/18) — PAGE 3
WORK SAFELY!
Only a
qualified service technician
with proper training
should perform this installation. Follow all shop safety rules
when performing this installation.
AIR COMPRESSOR SAFETY
DANGER
NEVER
operate the equipment in an
explosive atmosphere or near combustible
materials. An explosion or fire could result,
causing
severe bodily harm or even death
.
WARNING
NEVER
disconnect any
emergency or safety devices.
These devices are intended for operator safety.
Disconnection of these devices can cause
severe injury,
bodily harm or even death
. Disconnection of any of
these devices will void all warranties.
CAUTION
NEVER
lubricate components or attempt service on a
running machine.
Fuels, fluids, coolants, lubricants, and battery electrolyte
used in the air compressor are typical of the industry.
Care should be taken to avoid accidental ingestions and/
or skin contact.
Make sure the air pressure reads
zero
before performing
any maintenance.
ENGINE SAFETY
CAUTION
NEVER
touch the hot exhaust manifold,
muffler or cylinder. Allow these parts to cool
before servicing the equipment.
BATTERY SAFETY
DANGER
DO NOT
expose the battery to open flames,
sparks, cigarettes, etc. The battery contains
combustible gases and liquids. If these
gases or liquids come into contact with a
flame or spark, an explosion could occur.
CAUTION
ALWAYS
disconnect the
NEGATIVE
battery terminal
before performing service on the generator.
PREPARATION
1. Make sure the air compressor is turned
OFF
and the
engine is cool.
2. Place the air compressor in an area free of dirt and
debris. Make sure it is on secure level ground with
chock blocks underneath each wheel to prevent it
from rolling.
BATTERY DISCONNECTION
1. Open the battery-side cabinet door to access the
battery (Figure 2).
Figure 2. Battery Cable Disconnection
2. Disconnect the negative cable (
BLACK
) from the
negative (
−
) terminal on the battery. See Figure 2.
NEGATIVE
(BLACK)
CABINET DOOR