Montigo DIVINE H42DFL, Installation & Maintenance Manual

Page: 28 / 54

Installation
XG0228 - 021419
6HFWLRQ)XHO&RQYHUVLRQ
ȏ 9HULI\WKDW\RXUȴUHSODFHLVFRPSDWLEOHZLWK\RXUDYDLODEOHJDVW\SH
(Natural Gas or Propane shown by "N" or "L" in your model number
ȏ If gas type is not compatible, contact your local Montigo representative.
ȏ &RQYHUVLRQNLWVPXVWEHLQVWDOOHGE\DTXDOLȴHGVHUYLFHWHFKQLFLDQ
Section 5-2: Gas Pressure
ȏ Optimum appliance performance requires proper input pressures.
ȏ *DVOLQHVL]LQJUHTXLUHPHQWVZLOOEHGHWHUPLQHGLQ$16Ζ=1)3$
1DWLRQDO)XHO*DV&RGHLQWKH86$DQG&$1&*$%LQ&DQDGD
Pressure requirements (during operation):
ȏ The manifold outlet pressure is set from the factory to the appropriate
SUHVVXUHEXWVKRXOGEHYHULȴHG
ȏ 7RFKHFNSUHVVXUHVFRQWUROYDOYHVKDYHDSURYLVLRQWRUHPRYHDȋ
137SOXJWREHȴWWHGZLWKDK6ΖRQO\
ȏ 0RQWLJRUHTXLUHVDVHUYLFHVKXWR΍YDOYHEHORFDWHGLQDQDFFHVVLEOH
location to isolate the gas supply.
ȏ 2QO\LQVWDOOJDVVKXWR΍YDOYHVDSSURYHGIRUXVHE\WKHVWDWHSURYLQFH
RURWKHUJRYHUQLQJERG\LQZKLFKWKHȴUHSODFHLVEHLQJLQVWDOOHG
Section 5-3: GAS CONNECTION
ȏ Flexible gas connectors must not exceed 3 feet in length, unless
allowable within local regulations.
ȏ &RQQHFWLQFRPLQJJDVOLQHWRWKHRUJDVLQOHWSRUW
ȏ
Purge all air out of gas line.
ȏ Check appliance connection, valve and valve train under normal
operating pressure with a commercially available leak check solution.
DO NOT USE A FLAME OF ANY KIND TO TEST FOR LEAKS.
PRESSURE REQUIREMENTS
Gas Pressure Natural Gas Propane
Minimum inlet pressure 5.5in. w.c. 11in. w.c.
Manifold pressure 3.5in. w.c. 10in. w.c.
Section 5: Installing the gas line
After gas line is connected, each appliance connection, valve and
valve train MUST be checked while under normal operating pressure
with either a Liquid Solution, or Leak Detection Device, to locate any
source of leak. Tighten any areas where bubbling appears or a leak is
detected until bubbling stops completely or leak is no longer detected.
DO NOT XVHDȵDPHRIDQ\NLQGWRWHVWIRUOHDNV$ȴUHRUH[SORVLRQ
will occur, causing serious injury, property damage or death.
DANGER
:KHQSUHVVXUHWHVWLQJWKHȴUHSODFHJDVOLQHDQGLQSXWV\VWHP
follow the appropriate local codes for your area. DO NOT connect
WKHȴUHSODFHWRSUHVVXUHVLQH[FHVVRI OE This will damage the gas
control valve.
Figure 18. 3UHVVXUH5HTXLUHPHQWV
Figure 18.b *DVΖQOHW6XSSO\ORFDWLRQ
+*DVOLQH
access
+*DVOLQH
access
+*DVOLQH
access
NOTICE
*$6
6833/<
*$6
6833/<
*$6
6833/<
:HUHFRPPHQGFDUHIXOFRQVLGHUDWLRQEHJLYHQWRWKHH΍HFWVRI
elevated mantel temperatures which may be in excess of product
design, for example: candles, plastic or pictures. This can cause
melting, deformation, discoloration or premature failure of T.V. radio,
and other electronic components.
CAUTION