Trouble Recovery
A. Loosen air vent screw.
1. Is choke knob pulled out?
A. Return to home position.
1. Is carburetor clogged?
A. Contact Customer Service.
1. Is fuel joint connection incorrect?
A. Connect correctly.
1. Is throttle cable adjustment incorrect?
A. Contact Customer Service.
Engine power loss.
1. Is propeller damaged?
A. Have propeller repaired or replaced.
1. Is propeller pitch or diameter incorrect?
A. Install correct propeller to operate outboard
at its recommended speed (r/min) range.
1. Is trim angle incorrect?
A. Adjust trim angle to achieve most efficient
operation.
1. Is outboard motor mounted at incorrect
height on transom?
A. Have outboard motor adjusted to proper
transom height.
1. Is boat bottom fouled with marine growth?
A. Clean boat bottom.
1. Is spark plug fouled or of incorrect type?
A. Inspect spark plug. Clean or replace with
recommended type.
1. Are weeds or other foreign material
tangled on gear housing?
61
A. Remove foreign material and clean
lower unit.
1. Is fuel system obstructed?
A. Check for pinched or kinked fuel line or
other obstructions in fuel system.
1. Is fuel filter clogged?
A. Clean or replace filter.
1. Is fuel contaminated or stale?
A. Fill tank with clean, fresh fuel.
1. Is spark plug gap incorrect?
A. Replace spark plug.
0. Is spark plug wiring damaged or poorly
connected?
A. Check wires for wear or breaks. Tighten all
loose connections. Replace worn or broken
wires.
1. Are electrical parts malfunctioning?
A. Contact Customer Service.
1. Is specified fuel not being used?
A. Replace fuel with specified type.
1. Is specified engine oil not being used?
A. Check and replace oil with specified type.
1. Is thermostat malfunctioning or clogged?
A. Contact Customer Service.
1. Is air vent screw tightened?
A. Loosen air vent screw.
1. Is fuel pump malfunctioning?
A. Contact Customer Service.
1. Is fuel joint connection incorrect?
Summary of Contents for MOTOR6
