Kato Imer CARRY 110, Operating Instructions Manual

Page: 38 / 51

3 MAINTENANCE
MINIDUMPER
CARRY 110
30
3.5 250 HOURS MAINTENANCE AND CHECKS
3.5.1 ENGINE OIL CHANGE
•
Check the condition: daily.
•
Change the oil after 250 hours of operation or if its condition makes an oil change imperative.
Refer to paragraph 3.4.1 of this manual and the engine instruction manual for the oil change procedure.
Note: always observe the established regulations governing the disposal of exhausted oils and filters.
3.5.2 REPLACING THE AIR FILTER ELEMENT
•
Check the condition: daily.
•
Replacement: After five cleaning cycles, after a year or when any part of the cleaner is damaged.
Refer to point 3.4.5 of this manual for the replacement procedure
Note: always observe the established regulations governing the disposal of exhausted filters.
3.5.3 DRIVE MOTOR REDUCER GEAR OIL LEVEL CHECK
•
Check the condition: after 200 hours of operation.
1. Orient the reducer so that the drain cap (1) is pointing down.
2. Remove the oil level/filler cap (2). The oil should be at the rim of the open oil level
hole.
3. Top up to the rim if necessary.
4. Clean the oil level / filler cap and apply sealant. Replace the cap.
5. Repeat with the other reducer gear.
Level/filler cap
Drain cap
I
F THE AMOUNT OF OIL HAS INCREASED TO AN ABNORMAL EXTENT
,
CHECK
THE HYDRAULIC MOTOR OIL SEAL
;
IF YOU FIND LEAKS
,
CONTACT THE
ASSISTANCE SERVICE
.
CAUTION