2
OPERATING INSTRUCTIONS
MINIDUMPER
CARRY 110
11
2.2
USING THE IC ENGINE
CHECKS BEFORE STARTING THE ENGINE
Check the hydraulic fluid, engine oil and fuel levels.
For these checks, see the section “Daily checks” in this manual.
This paragraph gives the basic instructions for starting the engine. However, you must supplement this information by
referring to the engine manufacturer’s manual supplied with the machine and kept in the document compartment.
2.2.1 STARTING THE ENGINE
STARTING AT NORMAL TEMPERATURE
1. Move the throttle lever (E) to the middle position.
2. Turn the key (I) to “ON”. Indicators (L) “battery charge”,
(M) “oil pressure”, (N) “water temperature” and (O)
“glowplug preheating” turn on.
3. Wait a few seconds for indicator (O) “glowplug
preheating” to turn off.
4. Turn the key (I) to “START” and wait for the engine to
start. Release the key (I) once the engine has started.
Indicators (L) (M) and (N) turn off. Do not run the starter
motor for more than 15 sec. If the engine does not start
after 15 sec., allow it to cool down for 2 minutes and try
again. Turn the key (I) to “OFF” before attempting to
start the engine again.
5. Reduce the engine speed to allow it to warm up.
STARTING AT LOW TEMPERATURE
1. Repeat the procedure given in point 1 of the paragraph
“STARTING AT NORMAL TEMPERATURE”
2. Turn the key to “HEAT” to preheat the interior of the
engine. After around 15 seconds indicator (O) “glowplug
preheating” turns off. This indicates that the engine is
ready to be started.
3. Repeat the procedure given in points 4 and 5 of the
paragraph “STARTING AT NORMAL TEMPERATURE”
2.2.2 SWITCHING OFF THE ENGINE
Move the throttle lever (E) to minimum speed, and turn the
key (I) to “OFF”.
2.3
PREHEATING THE MACHINE
For all hydraulic systems, the hydraulic fluid must be up to temperature before they are operated.
The time required to preheat the fluid can be spent in running maintenance checks. Before operating the machine at full
load let the engine heat up slowly at low speed for 5 minutes.
Summary of Contents for CARRY 110
Page 2: ......
Page 49: ...TRACKED MINIDUMPER CARRY 110 PUBLISHED MARCH 2017 KATO IMER S p A ITALY ...
Page 50: ......
Page 51: ......