Jason International, Inc. •
501.771.4477
Page 3 of 18
Customer Service : 800.255.5766
Copyright © 2014 Jason International.
INSTALLATION INSTRUCTIONS (cont.)
10.
Protect the acrylic bath surface from damage
during installation with a suitable material, i.e.,
cardboard and/or plastic film.
The acrylic surface
of this bath has been provided with a protective film
which helps protect the bath during shipment and
installation. Additional protection may also be required
to protect the acrylic surface during installation. If the
bath is tiled in, remove the necessary portion of the
film when installing the tile.
FIELD INSTALLATION OF THE MICROSILK
®
PUMP
ASSEMBLY
The Jason MicroSilk
®
system has been factory assembled
following ETL and IAPMO guidelines. For shipping
purposes, on some bath models, the MicroSilk
®
Pump
Assembly may be packaged separately and disconnected
from the bath.
NOTE: These instructions can also be found in the
Installation, Operation and Maintenance manual of the
separately packaged MicroSilk
®
hydrotherapy bath
unit.
Fu ll Su p p o r t B a s e
Figure 3
Figure 4
WARNING: SYSTEM UNDER PRESSURE – NEVER
PERFORM MAINTENANCE WHILE SYSTEM IS RUNNING.
Note:
Verify the MicroSilk
®
Pump Assembly is the same
unit that was provided for the bath being installed. The
serial number listed on the label provided on the MicroSilk
®
Pump Assembly carton should match the serial number of
the bath.
WARNING: Any modification to the equipment is not
recommended and will VOID the manufacturer’s
warranty.
To install the MicroSilk
®
Pump Assembly to the bath, the
following procedures must be followed.
Note:
Do not install the MicroSilk
®
Pump Assembly further
than the length of the tubing that is factory installed on the
bath. These tubing lengths have been designed for proper
drainage of the system.
1. Position the bath in the area of intended installation.
2. Before beginning any work, the installer is to determine
the proper location of the MicroSilk
®
Pump Assembly
and service access.
3. Do not disconnect the plumbing lines that are secured
to the bath with nylon tie straps
(Figure 5)
.
Figure 5
