After servicing vehicle, remove any oil or grease left in the lift area.
If any abnormality are found, contact the lift supplier. Lower the lift
down to floor, and turn off the power.
vehicle falling accidents and personal accidents) and to ensure that lift can be
used for a long time, which are performed along with the Pre-Operation Check.
Check that is performed everyday in order to ensure that lift can be used safely.
In the event when even slightly abnormal condition arises during routine use of the
lift, immediately suspend the use of the lift and make sure lift to be repaired
properly and verify safety before using the lift.
Request the lift supplier where the lift was purchased for repairs on abnormality.
Clicking Sound during lifting operation
Lubricating Spot
Grease Fittings
Lubricate grease
Air Circuit
Air Joint & tubes
Any crack or air leak ?
Electric Components
Bolts & Nuts
Loosening
Any loosening ?
Lift Unit
Rust condition
Any rust ?
→ Does Stopper work when Slide Arm is fully
pulled out ?
・Arm Thickness
→ Does Stopper work without fail when Pads
are rotated and reached to top ?
Pad by hand up and down ?
・Drain of inside Pit Case → Is water drained ? And any obstacles ?
This lift use Gear Pump and the function and performance depends on the oil
used. If add, or replace oil, use the below grade oil. Oil need to be replaced
one year after installation, and then every 3 years.
Inside Pit
・Operation of Arm Stopper
Arms
→ Arm thickness is within standard range ?
Adjustable Supporter
・Operation of Stoppers
・Loosening
→ Is looseness within 2mm when moving the
Lowering Stop Device
Sound of Lowering Stop Hook
Control Panel
Operation Check. Any damage, loose terminal ?
Regular inspections are essential inspection procedures to secuere safety (preventing
Be sure to perform Regular Inspection at least once a month in addition to Pre-Operation
(Magnet Contactor, Relay etc.)
Have a qualified service personnel perform a periodical inspection once a year in addition
to the regular inspection described above. Request the lift supplier where lift was
purchased for periodical inspection performed.
