Any damage, strain or distortion ?
Visual
Does lift rise and lower smoothly without
noise ?
Is there any obstacles inside pit ?
Does Link and Shoe work properly ?
show 0.7 Mpa ?
Drain by Drain Valve
everyday ?
Refer to Page 16
Any oil leak from Hyd. Unit ?
Visual
Any abnormnal noise from Motor, Pump during
lifting and lowering ?
Any oil leak ?
Visual and touching
Visual and touching
Does system operate without fail ?
Does safety device make "clicking" noise
during lifting operation ?
Are both Right and Left side Lowering Stop
Hook released without fail in lowering ?
Does Lowering Stop Hook engage at the top
with "clicking" noise ?
Are both Right and Left side Lowering Stop
Hook released without fail in lowering ?
Can all 8ea.leg be kept horizontal or
vertical position ?
Any damage on Turning Radius Gauge ?
Visual
Does Wheel Stop work properly ?
Visual
Wheel Stop
Link Mechanism and
Slide Shoe
Visual
Lift Structure
Lift
Visual and hearing
Visual and Adjust
Any damage on Hyd. Hose, air hose and piping ?
Hydraulic Cylinder
and Piping
Lowering Stop Device
on Lower Lift
Visual and hearing
Visual and hearing
Is water drained from Air Filter Regulator
Visual and hearing
Any abnormality in Air and Electrial System ?
Air and Electrial System
Visual and hearing
Hydraulic Unit
Does Pressure Gauge of Air Filter Regulator
Operation
(Only Model MUL30H)
Remote Control Switch
and Flexibile Cable
Any damage, wear ?
Visual
Visual and hearing
Visual and hearing
Lowering Stop Device
on Upper Lift
If any possible abnormality is detected, prohibit the use of the lift until abonormality is
fully repaired. Then contact your lift supplier immediately. If the lift is used with
abnormality left unsolved, damage to the lift or serious accident may occur.
Caution
