Toro 30488, Руководство оператора

Страница: 32 / 60

g012916
7
6
5
4
3
2
1
8
9
10
11
Figure 38
1. J-bolt 7. Wing nut
2. Positive cable 8. Negative cable
3. Washer 9. Rubber cover (black)
4. Nut (5/16 inch) 10. Bolt
5. Rubber cover (red) 11. Battery
6. Battery hold down
Checking the Battery-Electrolyte Level
Service Interval: Every 25 hours
DANGER
Battery electrolyte contains sulfuric acid which is a
deadly poison and causes severe burns.
• Do not drink electrolyte and avoid contact with
skin, eyes or clothing. Wear safety glasses to
shield your eyes and rubber gloves to protect
your hands.
• Fill the battery where clean water is always
available for flushing the skin.
1. Look at the side of the battery. The electrolyte must
be up to the
upper line ( Figure 39 ). Do not allow the
electrolyte to fall below the Lower line ( Figure 39 ).
Figure 39
1. Vent caps 3. Lower line
2. Upper line
2. If the electrolyte is low, add the required amount of
distilled water; refer to
Adding Water to the Battery
(page 32) .
Adding Water to the Battery
The best time to add distilled water to the battery is just
before you operate the machine. This lets the water mix
thoroughly with the electrolyte solution.
1. Remove the battery from the machine; refer to
Removing the Battery (page 31) .
Important:
Never fill the battery with distilled
water while the battery is installed in the machine.
Electrolyte could be spilled on other parts and
cause corrosion.
2. Clean the top of the battery with a paper towel.
3. Remove the vent caps from the battery ( Figure 39 ).
4. Slowly pour distilled water into each battery cell until
the electrolyte level is up to the Upper line (
Figure 39 )
on the battery case.
Important:
Do not overfill the battery because
electrolyte (sulfuric acid) can cause severe
corrosion and damage to the chassis.
5. Wait for 5 to 10 minutes after filling the battery cells.
6. Add distilled water, if necessary, until the electrolyte
level is up to the Upper line (
Figure 39 ) on the battery
case.
7. Install the battery-vent caps.
32