SUNWARD SWE50B, Руководство по эксплуатации и техническому обслуживанию

Страница: 112 / 197

105
5.5.7.3 Replace Engine Oil, Oil Filter
For detail, refer to chapter 5.5.2.1.
5.5.7.4 Replace Fuel Filter
For detail, refer to chapter 5.5.2.3.
5.5.7.5 Replace Fuel Preliminary Filter
For detail, refer to chapter 5.5.2.4.
5.5.7.6 Clean Up Cooler
For detail, please refer to chapter 5.5.3.2.
5.5.8 Every 1000 Hours Service
Carry out EVERY 50 HOURS, EVERY 100 HOURS and
EVERY 250 HOURS, EVERY 500 HOUR at the same time.
5.5.8.1 Replace swing redactor gear oil

Stop the machine at level ground.

Stop auto-idle switch, run the engine unloaded at low speed
for 5 minutes.
【
Important
】

Stopping the engine improperly may damage
turbocharger.

Set start key to OFF position, stop the engine, remove the
key from starting lock, set safety lock lever to LOCK
position.
Note

After completing work, the gear oil temperature might be
very high, wait for temperature to cool down.

Place a container under drain pipe to collect oil.

Loosen drain plug to drain the oil, and then tighten the
plug.

Remove oil fill end cover, add specified gear lubricate oil.

Remove dipstick of swing redactor, wipe off oil with clean
cloth, re-insert dipstick, then pull out again, the mark of oil
should be between two scales.

If the oil level doesn’t reach mark L, add oil through oil fill
port, if the oil level exceeds mark H, drain excessive engine
oil and check oil level again.