19
10 Troubleshooting
Symptom
Component
Potential Cause and Remedy
The lamp does
not emit any
light
Power supply
- Check whether all cables are connected to the power
supply properly
- For this, follow the respective instructions of the power
supply manufacturer
- Check whether the power supply is plugged in
- Check whether the voltage from the power supply to the
source of radiation is +48 V DC
Temperature fault
If the lamp displayed a temperature fault, no light will be
emitted until the lamp has reached a safe operating
temperature. (see also: Water-cooling below)
SPS control
See 5.1 ‘SPS Connection’ for troubleshooting the interface
DB15. It is possible to test-run the lamp without SPS. Turn
on the lamp with full intensity with the following bridges to
the DB15 interface:
- Turn on the lamp with a low signal: Bridge between pin 4
and pin 10
- Emergency shut-off functionality: Bridge between pin 7 and
grounding pin 14
- Lamp output: Bridge between pin 2 and pin 6
SLM error
- Check the wiring of the DB15 connection; see 5.1 ‘SPS
Connection’ for this.
- If the outlet pin 11 from the DB15 is applied to the ground
(0 to +0.4 V DC), then it is possible that an internal fuse
was set off. For further information, contact Nordson EFD.
Temperature
increase of the
lamp by more
than 15°C
Water-cooling
- Check for the proper coolant through-flow
- Check the coolant temperature at the coolant inlet of the
lamp (m20 °C)
- If the lamp briefly (< 5 minutes) displayed a temperature
fault, check whether the temperature of the lamp is less
than +40 °C. To determine the internal temperature of the
lamp, you will need a voltmeter. Measure on pin 15
against the ground (+2 V = +20 °C).
Film on the
inside of the
glass window
of the lamp
Water-cooling
Check the environmental conditions of the light source for
potential signs of condensation. The film could be formed by
the collection of condensation on the inside of the lamp.
Содержание BlueCure FL
Страница 2: ...2...
Страница 20: ...20 A Appendix A 1 Drawing of the BLUE CURE FL 8 0W 125X20 WC 395...
Страница 21: ...21...