TER Ceska
Flex EX 4, Flex EX 6
Instruction manual
THE OPERATOR SHOULD NOT ATTEMPT TO REPAIR ANY RADIO CONTROLLER. IF ANY PRODUCT
PERFORMANCE OR SAFETY CONCERNS ARE OBSERVED, THE EQUIPMENT SHOULD IMMEDIATELY BE TAKEN
OUT OF SERVICE AND BE REPORTED TO THE SUPERVISOR. DAMAGED AND INOPERABLE RADIO CONTROLLER
EQUIPMENT SHOULD BE RETURNED TO TER FOR EVALUATION AND REPAIR. FAILURE TO FOLLOW THIS
WARNING COULD RESULT IN SERIOUS INJURY OR DEATH AND DAMAGE TO EQUIPMENT.
3.5. TRANSMITTER UNIT
•
Transmitter switches should never be mechanically blocked ON or OFF.
•
When not in use, the operator should turn the transmitter OFF.
•
A secure storage space should be provided for the transmitter unit, and the transmitter unit should always be placed
there when not in use.
•
This precaution will help prevent unauthorized people from operating the material handling equipment.
•
Spare transmitters should be stored in a secure storage space and only removed from the storage space after the
current transmitter in use has been turned OFF, taken out of the service area and secured.
3.6. PRE-OPERATION TEST
At the start of each work shift, or when a new operator takes control of the crane, operators should do, as a minimum, the
following steps before making lifts with any crane or hoist:
•
Test all warning devices.
•
Test all direction and speed controls.
•
Test the transmitter emergency STOP.
3.7. BATTERIES
WARNING
KNOW AND FOLLOW PROPER BATTERY HANDLING, CHARGING AND DISPOSAL PROCEDURES. IMPROPER BATTERY
PROCEDURES CAN CAUSE BATTERIES TO EXPLODE OR DO OTHER SERIOUS DAMAGE. FAILURE TO FOLLOW THIS WARNING
COULD RESULT IN SERIOUS INJURY OR DEATH AND DAMAGE TO EQUIPMENT.
•
Use only batteries approved by TER for the specific product.
•
Do not dispose of a battery pack in fire, it may explode.
•
Do not attempt to open the battery pack.
•
Do not short circuit the battery.
•
Keep the battery pack environment cool during charging operation and storage (i.e., not in direct sunlight or close to
a heating source).
3.8. BATTERY CHARGING
•
For those transmitters equipped with battery chargers, please familiarize all users with the instructions of the
charger before attempting to use.
•
Do not attempt to charge non-rechargeable battery packs.
•
Avoid charging partially discharged rechargeable batteries to help prolong battery cycle life.
•
Avoid charging the battery pack for more than 24 hours at a time.
•
Do not charge batteries in a hazardous environment.
•
Do not short the charger.
•
Do not attempt to charge a damaged battery.
Page 6 of 27
December 2015
