Landoll Brilllion Till'N Seed BPSB-8, Руководство оператора

Страница: 38 / 76

3-6 F-1097-2305
OPERATION
TABLE OF CONTENTS
Hydraulic Lift System
The Drawbar Till 'N Seed is equipped with a Hydraulic Lift
System to raise and lower the unit in the field.
WARNING
Figure 3-6: Hydraulic Leak Detection
The Hydraulic System is not filled with oil and should be
purged of air before transporting and field operations.
1. Tractor must be hitched to the Till 'N Seed Drawbar
and the Hydraulic Hoses connected.
2. Check to make sure the Tractor Hydraulic Reservoir
is full of the manufacturer’s recommended oil.
3. If the Transport Locks are engaged, raise the Till 'N
Seed and disengage the Transport Locks. See
Figure 3-5.
4. Slowly raise the Seeder until both Lift Cylinders are
fully extended. Lower and raise the Till 'N Seed to
verify that both Cylinders are working throughout the
stroke. Fully extend the Lift Cylinders and continue to
hold the lever until both Cylinder Rods movement
stops. Raise/Lower Seeder 5 times to purge air from
the system.
5. Do not loosen any Hydraulic Hoses or Fittings.
6. Recheck Tractor Reservoir to make sure it is within
operating limits.
7. Raise the Till 'N Seed and install Transport Locks.
See Figure 3-4.
Lift Circuit approximate oil requirement: 0.9 gallons.
Air Shock
DANGER
DANGER
The Till 'N Seed has a pair of Air Shocks that provides
down force on the Tillage Rotor and a pair of Air Shocks
that provides down force to the Rear Firming Roller.
•
Air pressure can be increased or decreased through
the Schrader Valve on each Air Shock.
See
Figures 3-7 and 3-8.
Figure 3-7: Air Shocks Right Side
Figure 3-8: Air Shocks Left Side
Escaping hydraulic fluid can cause serious
personnel injury. Relieve system pressure before
repairing, adjusting, or disconnecting. Wear
proper hand and eye protection when searching
for leaks. Use cardboard instead of hands (See
Figure 3-6.) Keep all components (cylinders,
hoses, fittings, etc.) in good repair.
Wear Protective Gloves And Safety Glasses Or
Goggles When Working With Air Shock.
Pressurized Air Shock May Violently Extend If
Disconnected From Machine Without Releasing
Its Air Pressure Prior To Removing.
Schrader
Valve
Rear Firming
Roller Air Shock
Tillage Rotor
Air Shock
Schrader
Valve
Schrader
Valve
Rear Firming
Roller Air Shock
Tillage Rotor
Air Shock
Schrader
Valve