Jacobsen 10029194, Руководство по безопасности, эксплуатации и техническому обслуживанию

Страница: 59 / 148

B
BATTERIES
en-59 Safety, Operation, & Maintenance Manual
Lithium
BATTERIES
BATTERY SAFETY___________________________________________________
Charging should be performed when ambient temperatures are between 40°F and 110°F (4°C and 42°C). The battery
pack may be charged or topped off after every use.
The battery management system (BMS) and charger cooperate to make sure that charging occurs at the proper rate for
the battery temperature. When the battery charger is connected to the vehicle, it will determine the charge rate based on
the battery temperature. The charger will operate at the rates shown in the table below:
• The BMS will adjust the charge rate based on the temperature of the batteries.
• Use only the OEM approved Lithium-Ion battery charger for your vehicle. See charge operating instructions
for use.
• Turn the key to the OFF position and remove it from the vehicle.
• Inspect the charger cord for cracks, frayed wires or loose connections. If damaged, replace it.
• Inspect the vehicle charger receptacle and charger for dirt, debris or damage. Clean if necessary and
replace immediately if damage is found.
• Connect the charger to a wall receptacle. Do not use a multi-plug adapter or power strip. Do not connect
anything else to the same receptacle.
• When the battery pack is finished charging, disconnect the charger cord from the vehicle. If disconnecting
before the charge cycle is complete, it is recommended that the charger be disconnected from the wall
receptacle first, then unplug the charger from the vehicle receptacle.
BATTERY PROLONGED STORAGE_____________________________________
NOTICE: Improper storage may damage, destroy or cause permanent loss of battery capacity. Do not exceed
storage time or temperature limits. Batteries must be charged to the correct level before storage. Storing fully
depleted batteries will make them permanently unusable.
Storage Preparation
The optimum storage temperature range is between 65° and 82° (18° and 28°C)
• Charge the battery module based on climate during storage period.
• In cold climates, fully charge the battery module. Make sure that the charging operation is complete and
there are no faults displayed on the charger. The green light on the charger should be on, indicating the
charge cycle is complete.
• In hot climates, store the vehicle with a 30% to 50% charge of battery pack capacity.
• Turn the key to the OFF position and remove it from the key switch.
• Check the run-tow switch under the seat, make sure it is set in the RUN position.
• Turn off all accessories.
Charge Rate Temperature
NO charging below 14°F (-10°C) or above 140°F (60°C)
Pre-charge (charge at reduced rate, 21 amps) between 14°F (-10°C) and 41°F (5°C)
between 104°F (40°C) and 140°F (60°C)
Full charging between 37.4°F (3°C) and 107.6°F (42° C)