Iveco NEW DAILY, Инструкция по эксплуатации

Страница: 216 / 240

16
NEW DAILY
–
DAILY PEOPLE CARRIER
DAILY PEOPLE CARRIER
A.7
ROAD TESTS
–
Printed 603.95.789
–
1 Ed. - Base 02/2014
Pin Description Signal Observations
11 TGC OFF inlet 100 mA +12V = TGC OFF
12 TGC ON inlet 100 mA +12V = TGC ON
A.7 ROAD TESTS
a)
Before starting the road test, the following checks must be carried out with the vehicle stopped:
●
tyre pressure;
●
engine oil level, gearbox and rear axle, brakes and steering, water in cooling tank, battery status and fluid level;
●
parking brake operation;
●
door operation, emergency button sensitivity, check lights, windscreen wipers, windscreen washers, horn,external lights,
switching engine off from inside compartment;
●
bodywork alignment in relation to the chassis and suspension height;
●
no interference with steering controls, along the entire rotation path of the steering wheel;
●
correct operation and visibility of the warning lights and buzzers.
b) While driving a 50 km stretch of road in different driving conditions (flat road, windy roads, uphill, downhill, irregular road
surface), the following parameters must be checked:
●
no faulty vibrations or noise from the gearbox, rear axle, transmission or other chassis or bodywork assemblies;
●
correct operation of the mechanical gearbox;
●
braking progression and no excessive effort on the pedal;
●
progressive clutch action;
●
progressive steering action without resistance or knocks, maintaining vehicle trajectory without the need for repeated correc-
tions.
With regard to "system" operation, check:
●
no fault messages appear on the instrument panel and no danger or attention warning lights remain on;
●
The electric retarder has a brief response time and determines a progressive action in each of its actuations points;
●
The speed limiter does not cause any jolting;
●
activating the "battery OFF" switch stops the engine, activates the warning light and deactivates the battery;
●
the tachograph is sealed;
●
the heating and climate control unit work efficiently;
●
the internal and external acoustic levels comply with standards;
●
there are no infiltrations during or after driving through rain water/high pressure vehicle cleaning water jets.
As regards the ergonomics, check:
●
range, hardness or interference of the gear stick with benches or seats;
●
position and longitudinal and backrest adjustment of the driving seat;
●
any visual interference caused by the steering wheel in relation to the dashboard as well as the lighting and brightness of the
instrument panel.
c) At the end of the drive:
●
check for any leaks of water, oil, diesel, brake, steering or clutch fluid;
●
check and retighten the wheel nuts to 290-350 Nm.