Innovatech TERMINATOR-2000e, Руководство по эксплуатации и обслуживанию

Страница: 34 / 58

INNOVATECH PRODUCTS AND EQUIPMENT CO., INC. 34
HAZARDOUS MATERIALS IDENTIFICATION SYSTEM (HMIS)
Health Flammability
Reactivity BASIS
1 1 0 Recommended by Exxon
EXPOSURE LIMIT FOR TOTAL PRODUCT
BASIS
5mg/m
3
for oil mist (aerosol) for an 8 hr. Workday OSHA Regulation 29
CFR1910.000 and recommended by
the American Conference of
Governmental Industrial Hygienists
(ACGIH).
ACGIH states that the air is to be
sampled by a method that does not
collect vapor; in addition, it lists a 10
mg/m
3
STEL.
C. PRIMARY ROUTES OF ENTRY AND EMERGENCY AND FIRST AID PROCEDURES
EYE CONTACT
If splashed into the eyes, flush with clear water for 15 minutes or until irritation subsides. If irritation
persists, call a physician.
SKIN
In case of skin contact, remove any contaminated clothing and wash skin with soap and water.
Launder or dry-clean clothing before reuse. If product is injected into or under the skin, or into any part of
the body, regardless of the appearance of the wound or its size, the individual should be evaluated
immediately by a physician as a surgical emergency. Even though initial symptoms from high-pressure
injection may be minimal or absent, early surgical treatment within the first few hours may significantly
reduce the ultimate extent of injury.
INHALATION
Vapor pressure is very low. Vapor inhalation under ambient conditions is normally not a problem. If
overcome by vapor from hot products, immediately remove from exposure and call a physician. If
breathing is irregular or has stopped, start resuscitation; administer oxygen, if available. If overexposed
to oil mist, remove from further exposure until excessive oil mist condition subsides.
INGESTION
If ingestion, DO NOT induce vomiting; call a physician immediately.
D. FIRE AND EXPLOSION HAZARD INFORMATION
FLASH POINT (MINIMUM): 208
°
C (406
°
F); ASTM D92, Cleveland Open Cup
AUTO IGNITION TEMPERATURES: Greater than 260
°
C (500
°
F)
NATIONAL FIRE PROTECTION ASSOCIATION (NFPA) - HAZARD IDENTIFICATION
Health Flammability Reactivity BASIS
1
1 0 Recommended by EXXON
HANDLING PRECAUTIONS
Use product with caution around heat, sparks, pilot lights, static electricity, and open flame.
FLAMMABLE OR EXPLOSIVE LIMITS (APPROXIMATE PERCENT BY VOLUME IN AIR)
Estimated values: Lower Flammable Limit - 0.9%
Upper Limit - 7%