Gardner Denver AirSmart EAU99T, Руководство по эксплуатации и обслуживанию

Страница: 9 / 77

13-10-618 Page 8
LIST OF ILLUSTRATIONS
Figure 1-1 – Compression Cycle .................................................................................................................. 9
Figure 1-2 - Starter Box ............................................................................................................................... 10
Figure 1-3 – Package – Controller & Starters ............................................................................................. 10
Figure 1-4 – Package – Drive Motor & Air Filter ......................................................................................... 11
Figure 1-5 – Package – Oil Filter, Oil Level Gauge, Mixing Valve .............................................................. 11
Figure 1-6 – Package – Air/Oil Flow Diagram ............................................................................................. 12
Figure 2-1 – Typical Compressor Room ..................................................................................................... 14
Figure 2-2 – Air Flow Chart ......................................................................................................................... 14
Figure 2-3 – Cold Weather Installation ....................................................................................................... 16
Figure 2-4 – Inlet Line Lengths ................................................................................................................... 17
Figure 2-5 – Heat Exchanger Approximate Water Flow ............................................................................. 19
Figure 2-6 – Aftercooler Approximate Water Flow ...................................................................................... 19
Figure 2-7 – Series Piping........................................................................................................................... 20
Figure 2-8 – Parallel Piping ......................................................................................................................... 21
Figure 4-1 – Key Pad .................................................................................................................................. 30
Figure 4-2 – Schematic Tubing Diagram .................................................................................................... 31
Figure 4-3 – Blowdown Valve ..................................................................................................................... 32
Figure 4-4 – Minimum Discharge Pressure/Check Valve ........................................................................... 32
Figure 4-5 – Inlet Valve ............................................................................................................................... 33
Figure 4-6 – Shuttle Valve........................................................................................................................... 34
Figure 4-7 – Turn Valve Actuator (Sectioned) ............................................................................................ 35
Figure 4-8 – Control Schematic – Compressor At Full Load ...................................................................... 38
Figure 4-9 – Control Schematic – Compressor Fully Unloaded – Low Demand Mode Switch Off ............ 39
Figure 4-10 – Control Schematic – Compressor Fully Unloaded – Low Demand Mode Switch On .......... 40
Figure 4-11 – Wiring Diagram – Wye Delta .................................................................................... 41 thru 42
Figure 4-12 – Wiring Diagram – Wye Delta .................................................................................... 43 thru 44
Figure 5-1 – Dew Point Chart
°
F ................................................................................................................. 47
Figure 5-2 – Dew Point Chart
°
C ................................................................................................................ 47
Figure 5-3 – Flow Diagram.......................................................................................................................... 48
Figure 5-4 – Oil Flow Diagram – Remote Overhead Mounted ................................................................... 49
Figure 5-5 – Cooler Drain Detail ................................................................................................................. 50
Figure 5-6 – Oil Level Gauge ...................................................................................................................... 54
Figure 5-7 – Oil Change Interval ................................................................................................................. 54
Figure 5-8 – Approximate Oil System Capacities ....................................................................................... 56
Figure 5-9 – Thermostatic Mixing Valve Element ....................................................................................... 58
Figure 5-10 – Water Control Valve ............................................................................................................. 60
Figure 5-11 – Oil Separator......................................................................................................................... 61
Figure 6-1 – Heavy Duty Air Filter (Standard)
.....................................................................................................
65
Figure 7-1 – Installation Of Coupling Cushions .......................................................................................... 67