Frymaster FilterQuick FQG30-T, Инструкция по установке, эксплуатации и обслуживанию

Страница: 44 / 48

5-8
PROBLEM PROBABLE CAUSES CORRECTIVE ACTION
Top off
reservoir won’t
fill.
A.
Incorrect setup procedure.
B. Another function is in process.
C. Dispose valve not completely
closed.
D. Bulk oil tank is empty.
E. Solenoid, pump or switch issue.
A. Power cycle fryer by disconnecting
and reconnecting 5-pin bulk oil
control power cord on rear of fryer.
B. If a filtration or any other filter menu
function is in process or FILTER
NOW? YES/NO, CONFIRM YES/NO, or
SKIM VAT are displayed, wait until the
process is complete and try again.
C. Ensure the dispose valve handle is
pushed fully closed.
D. Call your bulk oil provider.
E.
Call you FAS for assistance.
Top off
reservoir or vat
filling slow.
Pump or line issues beyond the
scope of operator
troubleshooting. Contact your bulk oil provider.
5.6 Error Log Codes
See section 1.13.2.1 in the FQ4000 Controller manual for instructions to access the
Error Log.
Code ERROR MESSAGE EXPLANATION
E13 TEMPERATURE PROBE FAILURE TEMP Probe reading out of range. Call
service.
E16 HIGH LIMIT 1 EXCEEDED High limit temperature is past more than
410°F (210°C), or in CE countries, 395°F
(202°C)
E17 HIGH LIMIT 2 EXCEEDED High limit switch has opened.
E18 HIGH LIMIT PROBLEM
DISCONNECT POWER Vat temperature exceeds 460°F (238°C) and
the high limit has failed to open.
Immediately disconnect power to the fryer
and call service.
E19 HEATING FAILURE – XXX F or XXX C Heating Control latch circuit failed.
Heat Contactor failed to latch.
E25 HEATING FAILURE - BLOWER The air pressure switch(s) failed to close.
E27 HEATING FAILURE - PRESSURE SWITCH - CALL
SERVICE The air pressure switch has failed closed.
E28 HEATING FAILURE – XXX F or XXX C The fryer has failed to ignite and has locked
out the ignition module.
E29 TOP OFF PROBE FAILURE - CALL SERVICE ATO RTD reading out of range. Call service
E32 DRAIN VALVE NOT OPEN - FILTRATION AND
TOP OFF DISABLED - CALL SERVICE Drain valve was trying to open and
confirmation is missing
E33 DRAIN VALVE NOT CLOSED - FILTRATION AND
TOP OFF DISABLED - CALL SERVICE Drain valve was trying to close and
confirmation is missing
E34 RETURN VALVE NOT OPEN - FILTRATION AND
TOP OFF DISABLED - CALL SERVICE Return valve was trying to open and
confirmation is missing