Case CX490D, Руководство оператора

Страница: 21 / 370

1 - GENERAL INFORMATION
• Dispose of
DEF/A
D
B
LUE
® and any filter accumulations in accordance with all applicable Federal, State, and local
laws governing waste disposal.
US Environmental Protection Agency (EPA) Warranty Statement
CASE CONSTRUCTION warrants to the ultimate purchaser and each subsequent purchaser that the engine
is designed, built and equipped so as to conform with US Environmental Protection Agency (EPA) regulations
applicable at the time of manufacture and that it is free from defects in workmanship or material which would
cause it not to meet these regulations for a period of:
• 2 years or 1,500 hours of operation, whichever occurs first, for engines less than
19 kW ( 25 Hp )
• 5 years or 3,000 hours of operation, whichever occurs first, for engines greater than or equal to
19 kW ( 25 Hp )
NOTE: this warranty applies to all units operated in the United States or Canada.
Coverage
The model year, class of diesel engine, and emission application determination for your engine are identified on the
Emission Control Information Label. This label is affixed to one of the following areas of the engine: the top of en-
gine's rocker arm cover, the right-hand side of the oil pan, and the right-hand side of the engine front gear cover.
The warranty period begins on the date the new equipment is sold to the first retail purchaser. The presence of the
emission control label is the indication that the engine conforms to the applicable standards. Any emission control
system parts which are proven defective during normal use will be repaired or replaced during the warranty period.
The engine owner has responsibility to perform all the required maintenance listed in the Owner's Manual. CASE
CONSTRUCTION will not deny an emission warranty claim solely because no record of maintenance exists; however,
a claim may be denied if failure to perform maintenance resulted in the failure of a warranted part
It is recommended that replacement parts used for maintenance or repairs be CASE CONSTRUCTION Service Parts
to maintain the quality originally designed into your emission certified engine. The use of non- CASE CONSTRUC-
TION parts does not invalidate the warranty on other components unless the use of such parts causes damage to
warranted parts.
The manufacturer is liable for damages to other engine components caused by the failure of any warranted emission
control system part. CASE CONSTRUCTION is not responsible for failures resulting from improper repair or the use
of parts that are not genuine CASE CONSTRUCTION or CASE CONSTRUCTION approved parts.
Component coverage
New engines certified for sale and registered will have the following items covered by the emission warranty, depend-
ing on the emission level of the engine, if the items were first installed on the new engine as original equipment:
Fuel injection system
• Fuel injection pump
• Fuel injectors
• Fuel injection lines
Air induction system
• Intake manifold
• Turbocharger system (includes exhaust manifold)
• Charge air cooler
Positive Crankcase Ventilation (PCV) system (if
applicable)
• PCV valve
• Oil fill cap
Exhaust after treatment Devices (if applicable)
• Diesel Oxidation Catalyst (DOC)
• Diesel Particulate Filter (DPF)
• Selective Catalytic Reduction (SCR)
• Diesel Exhaust Fluid (DEF) tank and dispensing sys-
tems
Exhaust Gas Recirculation Systems (EGR)
• EGR valve assembly
• EGR cooler
Cold Start Enrichment Systems
Electronic Control Units, Sensors, Solenoids, and Wiring
harnesses used in above systems
1-13