Carefree FREEDOM FREESTYLE WM, Руководство по обслуживанию

Страница: 15 / 24

Carefree of Colorado Service Manual F
REEDOM
F
REESTYLE
WM
052573-301r8 11
M
OTOR
R
EPLACEMENT
1. Disconnect power to the awning.
2. If the awning is extended: Carefully push the lead rail toward the case
so that the arms collapse. While holding the lead rail in this position,
firmly tie the elbows of the spring arms together. Use a minimum 1/2"
rope - do not use bungee cords. When tying the rope, use a non-slip
knot such as a square knot or equivalent.
3. If the awning is closed: Firmly brace the lead rail in the closed
position. A second person can hold the lead rail steady during the
disassembly process.
CAUTION
Failure to secure the lead rail as described will allow the spring arms to
extend out suddenly possibly causing personal injury and damage to the awning.
R
EMOVE
O
LD
M
OTOR
1. Remove the two (2) screws holding the outer end cap. Set the cap and screws aside.
2. Disconnect the motor wire quick disconnects located under the outer cap.
3. Remove the harness wire from the cable channel in the case and on top of the arm. Allow the harness to
hang down loosely.
4. Remove the three (3) screws and spacer holding the inner end cap. Remove the two (2) motor screws.
CAUTION
If the awning is closed when the inner end cap is detached, the spring arms will
try to open. Continue to hold the lead rail closed.
5. Carefully pull the inner end cap away from the case and remove the motor wires from the end cap.
6. Slide the inner endcap down along the harness to clear the end of the case.
CAUTION
If the awning is closed when the motor is removed, the spring arms will try to
open. Support the roller tube and allow the awning to open slowly then secure the arms by tying the
elbows together as described previously.
7. Remove the fabric retaining screw then pull the motor out of the roller tube and set aside.
Fabric Slot
Retaining Screw
Motor
FF026
Inner Endcap
Motor Wire
Harness Wire
Plug Outer Endcap
Disconnect
Motor Wires
Harness Wire
Motor
Screws
Endcap
Screws
(x3)
Spacer
Remove Motor
Wire
Harness Wire
Inside View
Inner Endcap
Spacer
Marquee012
Spring Arms
Firmly Tie Elbows Together