ACP ARX1, Руководство по обслуживанию

Страница: 8 / 80

©2018 ACP, Inc.
Cedar Rapids, IA 52404 Page 8 of 80
Part No. 16400033
Original Instructions
SAVE THESE INSTRUCTIONS
1
ALWAYS operate the oven from an adequately
grounded outlet Do not operate on a two-wire
extension cord
2
Before servicing the oven (if oven is operable)
perform the microwave leakage test
3
The oven should NEVER be operated if the door
does not properly seat against the seal; the hinges
or hinge bearings are damaged or broken; the
choke is damaged, (pieces missing, etc); or any
other visible damage can be noted Check the
choke area to ensure that this area is clean and
free of all foreign matter
4
If the oven operates with the door open and
produces microwave energy, take the following
steps:
Tell the user not to operate the oven
Contact ACP ComServ immediately
5
ALWAYS have the oven disconnected when the
outer case is removed except when making the
“live” tests called for in the Service Manual DO
NOT reach into the oven area while the oven is
energized Make all connections for the test and
check them for tightness before plugging the cord
into the outlet
6
ALWAYS
ground the capacitors on the
magnetron filter box with an insulated-handle
screwdriver before working in the high voltage
area of the oven compartment Some types of
failures will leave a charge in these capacitors and
the discharge could cause a reflex action which
could make you injure yourself
7
ALWAYS remember that in the area of the
transformer there is HIGH VOLTAGE When the
oven is operating keep this area clear and free
of anything which could possibly cause an arc or
ground, etc
8
DO NOT for any reason defeat the interlock
switches There is no valid reason for this action
at any time; nor will it be condoned by ACP
9
IMPORTANT : Before returning an oven to a
customer, be sure to check for proper switch
interlock action
10
The microwave oven should never be operated
with any components removed and/or bypassed
or when any of the safety interlocks are found to
be defective, or when any of the seal surfaces are
defective, missing, or damaged
11
All microwave ovens meet all requirements of
the radiation control for Health and Safety Act
of 1968 Due to measurement uncertainties, the
maximum leakage for the field will be 4mW/cm2.
12
To ensure that the oven does not emit excessive
microwave leakage and to meet the Department
of Health and Human Services guidelines,
check the oven for microwave leakage using a
microwave oven leakage meter that complies
with US Government CDRH / FDA / DHHS
requirements and or any other local government
requirements The maximum leakage level
allowed by ACP is 4mW/cm2
13
If servicer encounters an emission reading
over 4mW/cm2, the servicer is to cease repair
and contact the ACP ComServ Department
immediately for further direction ACP will contact
the proper Government Agency upon verification
of the test results
Read the following information to avoid possible exposure to microwave radiation:
The basic design of the microwave oven makes it an inherently safe device to both use and service
However, there are some precautions which should be followed when servicing the microwave to maintain this
safety These are as follows:
IMPORTANT SAFETY INSTRUCTIONS
⚠
RECOGNIZE THIS SYMBOL AS A SAFETY MESSAGE
⚠
WARNING