Zetor HORTUS HS CL, Operator'S Manual

Page: 136 / 142

Towing with the Engine Running
Towing with the engine running can be performed if forced gearbox lubrication is ensured:
z
Engine speed between 1200 - 1300 rpm.
z
Maximum towing speed 8 km/h
z
Maximum towing distance 1 km
For towing the tractor use only a standard bar applied to the front towing hitch approved by the manufacturer.
Make sure to use the correct pin for the towing hitch and that it is secured with its locking pin.
Clean all lights required for road use, front and rear, and make sure they are in working order.
Before starting towing check the following conditions:
z
Unhitch any implement from the tractor;
z
Lock the two brake pedals together with the connecting latch;
z
Disengage the power take-off and differential locks;
z
Set the shuttle control lever and gear lever to neutral;
z
Move the range lever to the ''fast'' position;
z
Move the creeper lever to neutral;
z
Display the SMV (Slow Moving Vehicle) sign and turn on the rotating beacon and hazard lights
Warning: Switch on the hazard warning lights and revolving warning lights. Affix suitable
notices indicating that the tractor is being towed. Observe and follow the relevant national
regulations. Observe local safety regulations.
During road transfers observe the following instructions:
z
Wait until traffic thins before joining the road. Exert caution in the proximity of unregulated
intersections. Slow down until you have a clear view in both directions.
z
Keep in your lane and drive as close as possible to the kerb. If a tailback builds up behind you pull into
a lay-by as soon as possible to allow the traffic to pass.
z
When stopping the tractor (in any circumstances) apply the parking brake.
z
Travel speed must ALWAYS be such as to allow complete control and stability of the tractor in all
conditions.
Danger: Never attempt to tow the tractor with ropes (including steel ropes) because rope
breakage can cause serious injury.
Towing with the Engine Off
Important: With engine stopped and with forced gearbox lubrication system inoperative the
tractor can be transferred to a service centre only when loaded onto a transporter.
With engine stopped and with forced gearbox lubrication system inoperative the tractor should not be towed
except when safety is at risk.
TROUBLESHOOTING
135