![background image](http://html.mh-extra.com/html/york/ha090/ha090_technical-manual_947498003.webp)
TECHNICAL GUIDE
SPLIT-SYSTEM
AIR-COOLED
CONDENSING UNITS
MODELS: HA090
208/230/460
VOLT ONLY
208/230/575
VOLT ONLY
036-21338-001-C-0703
FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALE
®
DESCRIPTION
These Sunline 2000 units are completely assembled, piped and wired
at the factory to provide one-piece shipment and rigging. Each unit is
pressurized with a holding charge of refrigerant-22 for storage and/or
shipping.
The compact design, clean styling, low silhouette, and quiet operation
make these condensing units suitable for almost any outdoor location.
On rooftops…because they weigh much less than a single package
unit of similar capacity and are much easier to rig and support. At
ground level…because their ample sub-cooling capacity allows them
to be located 60 feet below the evaporator coil.
All sheet metal parts are constructed of commercial grade (G90) gal-
vanized steel. After fabrication, each part is thoroughly cleaned to
remove any grease or dirt from its surfaces. The external parts are
coated with a powder paint to assure a quality finish for many years.
This UL approved coating system has passed the 750 hour, 20% salt
spray test per ASTM Standard B117.
All models include a 1-year limited warranty on the complete unit. The
compressor carries an additional 4-year warranty.
A complete line of Evaporator Blower units is also offered to meet your
precise capacity and air handling requirements. Refer to Form 036-
21300-001 for more information on this air side equipment.
FEATURES
•
Condenser coil constructed of copper tubes and aluminum fins for
durability and long lasting efficient operation.
•
Permanently attached base rails with fork-lift slots and lifting
holes. This design allows for 3-way fork-lift access and overhead
rigging.
•
Both high and low pressure controls. Since these controls are
self-contained, there are no capillary lines to be damaged.
•
Compressor line-break motor protection and crankcase heaters.
•
Anti-short cycle timer to protect the compressor.
•
A lockout circuit to prevent the unit from cycling on safety control.
•
A 24-volt temperature control circuit.
•
Low ambient operation to 45
°
F
accessories for 0
°
F low ambient
operation are available.
•
A filter-drier (shipped in the unit's compressor compartment for
field installation near the evaporator coil).
•
Service valves with a back-seating access port for pressure test-
ing the system. Copper stub-outs are factory mounted on the suc-
tion and liquid service valves to simplify the field piping
connections.
•
Separate panel for easy access to the control box without affect-
ing air flow across the condenser coil.
•
Gauge lines extend out from cabinet to facilitate servicing.
•
Packaging suitable for outdoor storage
•
Optional coil guard accessory protect coils with a decorative grille.
http://www.rezine.net
Page 3
Summary of Contents for HA090
