starter motor to operate.
Crankshaft position sensor
- situated in the alternator cover. The crankshaft
position sensor detects movement of teeth attached to the alternator rotor. The
teeth give a reference point from which the actual crankshaft position is
calculated. The crankshaft position sensor information is used by the engine
ECM to determine engine speed and crankshaft position in relation to the point
where fuel is injected and ignition of the fuel occurs.
Engine coolant temperature sensor
- situated at the front of the cylinder head
near the thermostat housing. Coolant temperature information, received by the
engine ECM, is used to optimise fueling at all engine temperatures and to
calculate hot and cold start fueling requirements.
Oxygen sensors
- situated in the exhaust header pipe system close to the
cylinder head. The oxygen sensors constantly feed information to the engine ECM
on the content of the exhaust gases. Based on this information, adjustments to
air/fuel ratio are made.
Side stand switch
- situated at the top of the side stand leg. If the side stand is in
the down position, the engine will not run unless the transmission is in neutral.
Fall detection switch
- situated under the storage box. The fall detection switch
will detect if the motorcycle is on its side and will cut power to the ignition and fuel
systems immediately. This prevents the engine from running and the fuel pump
from delivering fuel. In the event of a fall, the switch is reset by returning the bike
to an upright position and switching the ignition off then back on again.
Gear position sensor
- situated in the lower crankcase, below the drive chain
front sprocket. The gear position sensor provides the engine ECM with selected
gear information. This is used to prevent the engine from starting if the
transmission is in gear. The sensor also provides information to the neutral lamp
in the instruments.
Sensor Locations
1
4
3
5
2
Gear position sensor
1.
Service Manual - Scrambler 1200 XC
387 of 640
Summary of Contents for Scrambler 1200 XC
