Skyjack SJ519 TH, Service Manual, Page: 79 / 108

79
SJ519 TH 216942AC
10 Hour or Daily Routine Maintenance Section 4 – Procedures
NOTE
Secondary or safety element should not be
removed unless it is being replaced.
Replace the secondary element if:
▪
Examination reveals tears or perforations in the
safety element.
▪
The primary element has been replaced three
times or the element has been in service one
year.
5.2-4 Check Hydraulic Oil Level
Maintaining the hydraulic components and
hydraulic oil at the proper level are essential to good
performance and service life of the telehandler.
The telehandler must be on level ground and all
cylinders retracted when checking oil level.
Refer to oil sight gauge at the right side of the inner
frame and check that the hydraulic fluid is between
MAX and MIN.
Hydraulic Tank
Sight Gauge
Hydraulic Tank
Filler
Figure 06 Hydraulic Oil Tank Sight Gauge
1. Check hydraulic Oil Tank Sight Gauge.
2. Add clean hydraulic oil through the tank filler
as required. Refer to
2.4 Recommended Fluids/
Lubrications for hydraulic oil specifications.
5.2-5 Drain Fuel/Water Separator
WARNING
Diesel fuel is flammable and may cause death
or serious injury. Shut down engine and do not
smoke while draining fuel/water separator.
1. Ensure engine is shut down & telehandler is
parked on a firm level surface.
2. Prepare a container for draining the fuel/water
separator and place it under the separator.
3. Open drain reservoir and allow approximately
one cup of fuel and any collected sediment
to drain into the container. Refer to the Figure
below.
4. Close the drain then dispose of the collected
liquid in an environmentally safe manner.
NOTE
Refer to your local/national environmental
regulations on how to dispose of used fuels and
other dangerous liquids.
5.2-6 Fuel Tank
WARNING
Do not allow fuel tank to become completely
empty. If tank is allowed to empty completely, the
entire fuel system will require bleeding.
1. Check fuel gauge inside operator’s cab.
2. Ensure fuel is at an appropriate level before the
start of each work shift.
3. Add diesel fuel as required.
NOTE
Refer to Operating Manual for refueling
procedure.
5.2-7 Check Parking Brake
1. Check the park brake operation daily or every 10
hours of service.