Section 07
FUEL SYSTEM
Subsection 02
(FUEL CIRCUIT)
SMR2000-055_07_02A.FM
07-02-5
Disconnect fuel lines from baffle pick up and loos-
en lower clamp
no. 7
.
TYPICAL
1. Disconnect fuel hoses
2. Loosen lower clamp
Disconnect wiring harness of fuel sender.
Remove baffle from fuel tank.
Remove upper clamp
no. 9
from adapter
no. 8
and slide adapter from baffle.
Push inward on the 3 clips at the base of the baffle
in order to remove the filter. Pry base off using a
small slotted screwdriver (if necessary).
Electric Fuel Pump
DI Models
Refer to ENGINE MANAGEMENT (DI) section.
Fuel Tank
RX/RX DI Models
NOTE:
It is necessary to remove the engine. Re-
fer to ENGINE section.
All Models
Siphon fuel tank.
Remove fuel baffle pick up or electric fuel pump
on
DI models
. See above.
Detach all fuel tank straps.
Pull out fuel tank.
INSPECTION
Fuel Filter
Carburetor-Equipped Models
Inspect fuel filter condition. Carefully use low
pressure compressed air to clean fuel filter. Re-
place filter if permanently clogged or damaged.
Fuel Filter Bowl
Check filter bowl for water contamination.
Gasket
Inspect gasket condition. Make sure gasket
no. 3
is well positioned into the filter bowl
no. 2
.
1. Gasket in bowl
DI Models
Inspect filter/strainer condition. Carefully use low
pressure compressed air to clean. Replace if per-
manently clogged or damaged.
The filter at fuel pump inlet is not replaceable indi-
vidually. The complete fuel pump unit has to be
replaced.
Fuel Filler Hose
All Models
Verify fuel filler hose
no. 4
for damage. Always en-
sure that clamps
no. 3
are well positioned and
tightened. Torque clamps to 4 N•m (35 lbf•
in
).
WARNING
Fuel is flammable and explosive under cer-
tain conditions. Always work in a well venti-
lated area. Always wipe off any fuel spillage
from the watercraft.
F02F1OA
1
2
WARNING
Ensure that there is no leakage from the fuel
filter.
F01F02A
1
www.SeaDooManuals.net
Summary of Contents for 2001 RX
