![background image](http://html1.mh-extra.com/html/palazzetti/ecofire-idro/ecofire-idro_installation-user-and-maintenance-manual_747784038.webp)
38/140
INSTALLATION MANUAL
- cod. 004771060 - 09/2011 - Palazzetti - PN - Italy
INSTALLATION
5.5 FLUE GAS EXHAUST
The stove operates with negative pressure in the
FRPEXVWLRQ FKDPEHU DQG FRQVHTXHQWO\ WKH ÀXH
gas discharge must be airtight.
The stove must be connected to its own separate
flue gas exhaust system capable of ensuring
adequate atmospheric dispersion of the combustion
byproducts.
7KHFRPSRQHQWVPDNLQJXSWKHÀXHJDVH[KDXVW
V\VWHPPXVWEHVXLWDEOHIRUWKHVSHFL¿FRSHUDWLQJ
conditions and bear the CE mark.
7KHSLSHVXVHGWRGLVFKDUJHWKHÀXHJDVPXVWKDYH
a nominal diameter of 8 cm with gaskets (up to 5
metres in length), or 10 cm with gaskets (for lengths
exceeding 5 metres) (Fig. 5.7).
7KHÀXHVVKRXOGEHVXLWDEO\LQVXODWHGHJXVLQJ
rock wool) or made using double wall steel pipes,
except for the initial vertical section inside the room.
An initial vertical section measuring a minimum of
PHWUHVLVUHTXLUHGWRHQVXUHFRUUHFWÀXHJDV
exhaust.
There should be at least three changes in direction
DORQJ WKH ÀXH LQ DGGLWLRQ WR WKH ÀXH FRQQHFWLRQ
at the rear of the stove, using 45 or 90° angle
connectors or ‘T’ connectors.
Use always a ‘T’ connector with inspection cap on
DOOKRUL]RQWDORUYHUWLFDOFKDQJHVLQÀXHGLUHFWLRQ
The maximum length of horizontal sections is 2-3
m with an upwards slope of 3-5% (Fig. 5.7).
$QFKRUWKHÀXHVWRWKHZDOOXVLQJVSHFLDOFROODUV
7KHÀXHJDVH[KDXVWDWWDFKPHQW0867127%(
connected to:
-
a chimney used by other heat generators
ERLOHUVVWRYHV¿UHSODFHVHWF
-
air exhaust systems (range hoods, vents,
etc.....) even if these are ducted.
Shut-off or draught valves must not be used.
Combustion byproducts must be discharged
through the roof.
,I WKH ÀXH LV ORQJHU WKDQ PHWUHV DQG WKHUH LV
LQVXI¿FLHQW GUDXJKW PDQ\ FKDQJHV LQ GLUHFWLRQ
unsuitable discharge terminal, etc.) flue gas
exhaust may be less than optimum. In these cases,
WKHRSHUDWLQJSDUDPHWHUVZLOOQHHGWREHPRGL¿HG
ÀXHJDVH[KDXVWDQGSHOOHWORDGWRDGDSWWKHVWRYH
WR WKH DFWXDO FKDUDFWHULVWLFV RI WKH ÀXH &RQWDFW
technical service for this procedure.
“E
RMETICA
”
SERIES
STOVES
For “Ermetica” series pellet stoves a special coaxial
SLSHFDQEHXVHGWRERWKGLVFKDUJHWKHÀXHJDVDQG
duct the combustion air from the outside (Fig. 5.5
A, B=Air intake C, D=Flue gas outlet).
Fig. 5.5
Fig. 5.6
Fig. 5.7
B
B
B
Ø 8 cm
Ø 8 cm
Ø 8 cm
MA
X 2
- 3
m
C >
3 -
5%
MA
X
2
-
3
m
A
A D
B
C