WINDROWER OPERATION
Form 169552 / 169554 / 169555
54
Revision A
CAUTION
Be sure the area is clear of other persons,
pets etc. before proceeding.
3. Single loud tone sounds, engine warning
lights illuminate, and CDM displays
“HEADER DISENGAGED” and “IN PARK”.
4. Turn ignition key to START position until
engine starts, and then release key.
IMPORTANT
Do not operate starter for longer than 15
seconds at a time. If engine does not start,
wait at least two minutes before trying
again. After the third 15 second crank
attempt, allow solenoid to cool for 10
minutes before further cranking attempts.
If engine still does not start, refer to
Section 8 TROUBLESHOOTING.
WARNING
If starter engages with steering wheel
unlocked, ground speed lever out of
NEUTRAL, or header clutch/drive engaged,
DO NOT START ENGINE. See your Dealer.
g.
Cold Start
- engine temperature below 40°F
(5°C).
1. Set throttle (D) to START position - “fully
back” (low idle).
2. Turn key (E) to RUN.
3. Grid heater light (F) on CDM will cycle ON /
OFF / ON after 2 seconds for a pre-set
length of time. The operating period for the
glow plug light will change depending engine
temperature.
4. When grid heater light goes out, turn key to
START, and crank engine until it starts.
Leave throttle at IDLE.
5. If engine fails to start, repeat steps 1 to 4.
6. Engine will cycle through a period where it
appears to labor.
NOTE
Throttle is non-responsive during this time
as engine is in “WARM UP” mode. This
mode will last from 30 seconds to
3 minutes depending on temperature.
After engine has stabilized and idling
normally, throttle becomes active.
IMPORTANT
Do not operate engine above 1500 rpm
until engine temperature is above 100°F
(40˚C).
IMPORTANT
Do not operate starter for longer than 15
seconds at a time. If engine does not start,
wait at least two minutes before trying
again. After the third 15 second crank
attempt, allow solenoid to cool for 10
minutes before further cranking attempts.
If engine still does not start, refer to
Section 8 TROUBLESHOOTING.
WARNING
If starter engages with steering wheel
unlocked, ground speed lever out of
NEUTRAL, or header drive/clutch engaged,
DO NOT START ENGINE. See your Dealer.
E
F
D
ENGINE TEMP 100°F