PLOW ANGLES SLOWLY
Perform all initial inspections and checks listed on page 2 before beginning test procedure.
PLOW ANGLES SLOWLY
ALL OTHER FUNCTIONS ARE NORMAL.
REMOVE, INSPECT AND CLEAN DIRECTIONAL VALVE.
SEE PAGE 17-18.
ADJUST PRESSURE. SEE PAGE 29-30.
DOES PLOW ANGLE FULLY LEFT AND
RIGHT FROM CENTER IN APPROXIMATELY 2 SECONDS?
Remove, inspect and clean Directional
Valve. See page 17-18.
Does plow angle fully left and right from en-
ter in approximately 2 seconds?
Check fittings and lift cylinder hose for ob
-
structions. Remove and drain oil from angle
cylinders. Check for a binding cylinder by
manually compressing and extending cyl-
inders by hand. Repair or replace as nec-
essary. Does plow angle fully left and right
from center in approximately 2 seconds?
Yes
No
Yes
No
End
Yes
No
Note:
Until pump system warms, slow functioning of the V-Plow will occur in extremely cold tempera-
tures unless a high quality oil that is appropriate for the temperatures in which you will be plow-
ing snow is used. See chart below.
Note:
Ensure vehicle battery is fully charged and alternator output is 13.6 Volts minimum with engine
running and no accessories on.
End
Call Hiniker Service
DWG NO. 3066
6 Plow Angles Slowly
WARNING: Never disconnect any hydraulic line or fitting with the unit in the raised posi
-
tion. Always lower the unit and relieve pressure before removing any lines or caps. Allow
the system to cool down before draining oil or handling system components. Serious
burns can result from contact with hot oil.
