CartManager XD+ Owner-Operator Training and Troubleshooting Guide
Page 10
SLOW
ON
OFF
FAST
HORN
POWER LED
Using CartManager XD+ – Remote Operations Mode
In remote operations mode, a handheld remote control unit is used to control the CartManager XD+, instead of the
throttle grips. The operator steers from the front of the line of carts.
1.
Make sure that the Emergency Stop button on the CartManager
XD+ is pushed in. This prevents the unit from unexpectedly
moving while you are loading carts.
2.
Load one cart onto the cart cradles, as shown in the figure at
right.
3.
Stand at the back of the CartManager XD+. Disengage the
Emergency Stop button.
4.
Turn the key switch to the ON position.
5.
Take the remote control unit and move to the side of the front of
the cart, facing away from the CartManager XD+.
6.
NEVER WALK DIRECTLY IN FRONT OF A LINE OF MOVING
CARTS!
7.
Turn on the Remote Control unit by pressing and immediately
releasing the green ON button. The Power Indicator will light
while the button is held down, and flash while the unit is on.
8.
Press and release the HORN button once or twice to alert
persons that you are in the area. If the horn does
not
sound:
9.
Turn off CartManager XD+.
10.
Turn on CartManager XD+ and immediately press and hold
the green ON button for 15-20 seconds. This establishes a
new radio link between CartManager XD+ and the remote.
You will only need to use this procedure if CartManager
XD+ fails to respond to the remote control unit, or if you are
using a different remote than the one usually used with the
CartManager XD+.
11.
With one hand on the front corner of the cart, press and
hold the SLOW (turtle) button. The CartManager XD+ will
begin to move slowly forward.
12.
While holding the slow button down, push the front of the
cart away from you. The cart and CartManager XD+ will
turn in that direction. Pull the cart towards you to move
back the other way.
13.
Release the slow button and CartManager XD+ will stop.
14.
Now press and hold the FAST (rabbit) button. CartManager XD+ will move forward, but much faster than when in
SLOW mode.
15.
Practice using the remote control to move a single cart.
When you are comfortable in both slow and fast modes, press the red OFF button to shut down the
remote control unit and go on to the next section,
Retrieving Carts
.
